Professional Documents
Culture Documents
Rain-Flo Irrigation: Assembly Instructions
Rain-Flo Irrigation: Assembly Instructions
ASSEMbLy InStRuctIOnS
Rain-Flo Irrigation
Rain-Flo Irrigation
(717) 445-3000
StEp 1
StEp 2
Rain-Flo Irrigation
Lynch Pin g
Remove lynch pin from hole on yellow arm and slide yellow arm through press wheel and into hinge underneath machine. Fasten in place with lynch pin. Secure chains to holes as shown.
Pr ess
Yellow Arm
he
el
Rain-Flo Irrigation
StEp 3
Chisel TeeTh
StEp 4
Rain-Flo Irrigation
Dirt Shield
Cover Disk
Rain-Flo Irrigation
Slide disk bracket over end of yellow bar and tighten in place with yellow lock handle. Install dirt shield as shown, by sliding end through hole and fastening with tee lock handle.
Chisel teeth are upside down for shipping. Rotate chisel tooth till tip is on bottom.
StEp 5
TrACTor hook-UP
StEp 6
A b
Drip Tape: Slide drip roll onto rod, press plate tight against roll(A) and Plastic: Place plastic rolls on top of rollers(A). Pull end of plastic down
tighten tee-handle on clamp. Slip drip tape through both rings(B) and into pipe(C). in between rollers and underneath bottom roller(B). Secure plastic and drip tape at end of row.
End ViEw
Plastic Roll Plastic Roll
Plastic