Professional Documents
Culture Documents
Suppo Osd V.1
Suppo Osd V.1
Typical FPV with OSD set up: (Video transmitter and Camera Not included)
1. 2. 3. 4. 5. 6. Connect Video in from your Camera Connect Video out to your wireless A/V transmitter Connect 5V power (from BEC Provided or other power source) to power up your OSD Connect GPS and select the right voltage for your GPS by setting the GPS Volt Jumper Connect your main power battery to monitor your main power battery voltage; Connect RSSI to your RC Receiver (Warning: potential dangerous, could damage your RX. not recommend to do so if you dont understand your RX well)
Edited by Foxit Reader Copyright(C) by Foxit Software Company,2005-2007 For Evaluation Only.
Setting and Configuring your OSD: Press Menu button to enter system configuration Use Option SW and Select button to configure
Setting RSSI Min Max value: 1. On ground power up TX and RX, press set home button, OSD will record RSSI Max; 2. On ground, power off TX, press Menu button, OSD will record RSSI Min value. 3. Select Save and Exit to save RSSI Min Max value. OSD Modules and accessory including: 1. OSD main modules; 2. GPS; 3. BEC; 4. Wires. Notes: 1. GPS first start will take 1-3 minutes. Re-start only 10 second. 2. Please note that you need to configure your HOME location with each time to get the right Flight Distance and Home Distance, and Return Course 3. Time shown is GMT 8, Pacific Time USA. Specifications: OSD Volt GPS Volt System Consumption 5V 3.3V 0.165A 0.825W BEC input BEC output 7-12V in 5V /1.5A Weight OSD GPS BEC 17.5g 15.5g 1.7g