Tai lieu nay chi dung cho ca nhan

CANH BAO NGOAI VI CSND E10 ALCATEL

ALARM BOX PAIR 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 Not on alarm box PIN 1_2 3_4 5_6 7_8 9_10 11_12 13_14 15_16 17_18 19_20 21_22 23_24 25_26 27_28 29_30 31_32 33_34 35_36 37_38 Fire Fire detection failure Break in Air conditionning HS Temperature danger Generator unit Generator unit Air conditionning Insulating fault CDE RSU miscellaneous 1 O.G. fuse Rectifier Rectifier Autonomy battery close Battery fuse Fuel low level Mains disconnect RSU miscellaneous 2 Mains not connect Switching Switching Transmission Disconnect TCRMT1 Disconnect TCOND Time base alarm Disconnect cut-out switch connect Transmission

DESIGNATION

TCPOS Alarm TYPE CATEGORY CONNECTOR 4 3 2 1 0 Nr. PIN PAIR Clr.PIN

0 0 0 0 0 0 0 0 0 1 0 0 0 1 0 0 0 0 1 1 0 0 1 0 0 0 0 1 0 1 0 0 1 1 0 0 0 1 1 1 0 1 0 0 0 0 1 0 0 1 0 1 0 1 0 0 1 0 1 1 0 1 1 0 0 0 1 1 0 1 0 1 1 1 0 0 1 1 1 1 1 0 0 0 0 1 0 0 0 1 1 0 0 1 0 1 0 0 1 1 1 0 1 0 0 1 0 1 0 1 1 0 1 1 0 1 0 1 1 1 1 1 0 0 0 1 1 0 0 1 1 1 0 1 0 1 1 0 1 1 00H 01H 02H 03H 04H 05H 06H 06H 08H 09H 0AH 0BH 0CH 0DH 0EH 0FH 10H 11H 12H 13H 14H 15H 16H 17H 18H 19H 1AH 1BH INC INC EFR CLI CLI ENP ENP CLI ENP COM DIV ENS ENS ENS ENS ENS DIV ENP DIV ENP COM COM ICT ICT IM ID IM IM IM IM ID ID ID IM ID IM IM ID IM IM ID IM IM ID IM ID IM ID Z1 Z2 Z3 Z4 Z5 Z6 Z7 Z8 Z1 Z2 Z3 Z4 Z5 Z6 Z7 Z8 Z1 Z2 Z3 Z4 Z5 Z6 Z7 Z8 Z2 Z3 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 Z7 Z8 2 1 Green Orange Grey Purple Blue Yelow Brown Black Green Sensor (1+3) Orange Grey Purple Blue Yelow Not use on alarm box Brown Black Green ZLALBF(black) Orange ZLALBF(brown) Grey Purple Blue Yelow ZLALBO(black) Brown Black ZLALBO(brown) Green Orange Grey Purple Earth Yelow Brown Not use on connector

Only display on TCPOS. Can't measure on back board.

Cable TLACH Cable 2*32CD 1AC003730001 Connector HE12-2*32SN 1AB010590010 Capot plastic 3*32C 1AB048870001 Cover 3*32c 1AB048870002 Screw 1AD002440005

On TCPOS:
If many alarm occur, each alarm display in 3 seconds.

N C Kien D V Thang 6-04

Tai lieu nay chi dung cho ca nhan

N C Kien D V Thang 6-04

Tai lieu nay chi dung cho ca nhan

use on alarm box

N C Kien D V Thang 6-04