Pres open the seam and pin
the bands together. Turn in
seam allowance on other edge and
fold strip to wrong side. If neces-
sary, trim seam allowances to lem
Q’). Stitch from right side through
seam,
To begin, interface the facing
with a piece the length of the
opening, plus 2cm (2") on the
lower edge, no seam allowance on
the front edge, and Lem (}") else-
where, Choose an interfacing suit-
able for the fabric being used. Iron
an iron-on interfacing into place or
baste on non-iron interfacing. Mark
center front, fold line on underlap,
end of the opening, buttons and
buttonholes with basting.
Stitch the center front seam to
the end of the opening. Cut
into the underlap as far as the fold
line as shown in the photograph
above. Finish edges of the cut.
i
§} Sulch the plat seam to about
10cm (4*) above the hem.
Press the pleat fold and press the
underlap facing to the inside along
the fold line. Finish the edges of
the facings, finishing the overlap
facing together with the pleat.
Stitch down the pleat as
follows: Stitch from the
finished edge of the facing up to
the center seam. Leaving in the
pins, turn the work and stitch up
the marked line of the center seam,
Leave the pins as before and turn
the work again and stitch the
underlap onto the overlap facing,
Press the overlap facing to the left
side along the marked line.
again near the fold edge to give a
firm finish. Work buttonholes and
sew on buttons,
@ Me, Photograph shows the
finished opening.