Professional Documents
Culture Documents
Cisco
Cisco
switch>enable
Password:*******
switch#
switch(config)#exit
switch#configure terminal
switch(config)#hostname NOME
switch(config)#exit
switch#
Switch 2950:
switch#config t
switch(config-if)#speed 100
switch(config-if)#duplex full
switch#configure terminal
switch(config)#interface vlan 1
switch(config-if)#exit
switch(config)#exit
switch#
switch#vlan database
VLAN 2 modified:
Name: NAME
OU
switch#config t
switch(config)#vlan 2
switch(config-vlan)#name NAME
Portas 3, 4 e 5 VLAN 2
switch#config t
switch(config-if)#exit
switch(config-if)#exit
switch(config-if)#exit
switch(config)#exit
switch#
8- Configurar TRUNK.
Switch 2950:
switch#config t
switch(config-if)#speed 100
switch(config-if)#duplex full
switch(config-if)#exit
switch(config)#exit
switch#show run
OU
Switch 2900:
switch#config t
switch(config-if)#speed 100
switch(config-if)#duplex full
switch(config-if)#exit
Switch 2950:
switch#config t
switch(config)#exit
OU
switch#config t
switch(config-if)#exit
switch(config)#exit
switch#config t
Switch(config)#end
Address or name of remote host []? X.X.X.X onde X o endereo IP do servidor FTP
Writing cisco/nomedoarquivo !
switch#config t
switch#config t
switch#config t
switch#config t
switch#config t
Switch#conf t
Switch 2950:
switch#config t
switch(config-if)# storm-control action shutdown //Caso atinja o limite acima porta ficar em shutdown//
switch(config-if)#exit
Switch 2900:
switch#config t
switch(config-if)# port storm-control broadcast threshold rising X falling Y //Onde rising X o limite superior em pacotes/seg e falling Y o limite inferior para a porta retornar ao estado up//
switch(config-if)# port storm-control broadcast action shutdown //Caso atinja o limite acima porta ficar shutdown//
switch(config-if)#exit
switch#config t
3- Pressionar o boto Mode e mant-lo pressionado enquanto reconecta o cabo de alimentao do switch. Mantenha o boto Mode pressionado dois segundos aps o led da porta 1X apagar.
The system has been interrupted prior to initializing the flash file system. The following commands will initialize the flash file system, and finish loading the operating system software:
flash_init
load_helper
boot
Switch: flash_init
Switch: load_helper
Note que o arquivo config.text o arquivo de configurao que contm as definies sobre a senha.
9- Bootar o switch
Switch: boot
10- Aps a inicializao do switch, aparecer a seguinte pregunta: Deseja entra no modo de configurao "dilogo"?
Digite no
switch> enable
Switch(config)# exit
Switch# write
Aps estes procedimentos a nova senha j estar includa no arquivo de configurao inicial.