Professional Documents
Culture Documents
This tutorial is to use SWAT in ArcMap 9.2. Copy to your folder Lab 5 SWAT data from \\GIS4 All user files MUST be in the same directory. All SWAT data has to be in one folder SWAT has to be installed in ArcGIS 9.2 prior to use and show up in tools extensions. Start ArcMap 9.2 and check, if SWAT appears.
Fill in spaces your Project directory, SWAT Project Geodatabase, Raster Storage, and SWAT Parameters Geodatabase.
Select the DEM input grid Load DEM grid from disk Select file: project_edcr1
It may take several minutes for the Click on Stream network and Create streams and outlets
Watershed Outlet(s) Selection and Definition Click on the Whole watershed outlet(s) - Select. Drag square on the outlet area you should get light blue dot.
Click exit
Follow steps
10
On the SWAT Land Use Classification Table click on the empty place beneath of LandUseSwat Select on the Land Cover Databse crop
11
Click Reclassify
12
13
14
Double-click on the boxes beneath Name and enter these names for the following value fields: (1) Precambrian (2) Llmestone (3) Sandstone (4) Alluvium
Reclassify
15
16
Click Overlay
17
In HRU (Hydrologic Response Units) Analysis Select Dominant Land Use, Soil, Slope
Review Reports
18
Rainfall Data
19
Temperature data
20
So, all your InputWeather Stations for each variable should be the following files (not bulleting the simulation button): Rainfall Data: precipssmi1.dbf Solar Radiation: solarradiationtable.dbf Temperature: temptable.dbf Wind Speed: windtable.dbf Relative Humidity: humtable.dbf Weather Simulation: Custom Database: wgnstations.dbf
Next Write All
21
22
23
24