Professional Documents
Culture Documents
ANSYS Pin Loaded Simulation PG 1 PDF
ANSYS Pin Loaded Simulation PG 1 PDF
We have a problem that we want to simulate the pin loaded lug as shown in figure below. Width of plate w=50mm Thickness of plate t=5mm Radius of pin hole R=10mm Force P=1000N
Pin loaded lug is simulated using the following theory and FEA techniques. 1. By theory 2. By FEA techniques (a) Nodal loading using Cosine curve (b) Nodal loading using half and full loads (c) Pressure loading using surface effect elements
By Theory
According to the theory, the nominal stresses in the component are n =P/dt =1000/20*5 =10 MPa The stress concentration factor for this case is 2.7 Kt = Therefore the actual stresses would be a = Kt n =2.7*10 = 27 MPa
By FEA techniques
Nodal loading using Cosine curve In this case, the, load is applied in the form of force using following relations. Pmax =2P/R P = Pmax Cos