Professional Documents
Culture Documents
Rev.1.Oct.10.2007
Build the 3 knob ToneBender on this board. This circuit uses positive ground, keep that in mind when using with other pedals (dont share the same power supply with negative ground pedals). Off board components except for the potentiometers are not shown on the layout. Trademarks are property of their owners. Visit www.tonepad.com for more!
-9v (black lead from battery snap)
100k-B
100k-B
100k-B
3 2 1
FUZZ D1 .22 47k 220p 220k 10k
3 2 1
TONE 220k .1 10k
3 2 1
VOLUME OUT 22uF + 2200p 10k
GND IN
18k 10k
1M .1
LAYOUT
0 1 1 2
READY TO TRANSFER Parts List Resistors 1 - 3k3 5 - 10k 1 - 18k 1 - 47k 2 - 220k 1 - 1M Capacitors 1 - 220pF 1 - 2200pF 2 - 0.1F 1 - 0.22F 1 - 10F 1 - 22F Pots 3 - 100kB Transistors Q1 - PNP Ge Q2 - PNP Ge Q3 - PNP Ge Diode 1 - 1N270
Schematic
-9V AC ADAPTOR
22uF
220k
10k 0.1uF
3
9v INPUT
+ .1uF Q1 Q2
2
18k
10k 2200pF
100kB
1
220k
Q3
100kB
1
Layout and presentation by Francisco Pea 2001-2007. All rights reserved. Authorization for personal use only, any commercial use is forbidden. Permission for posting/serving limited to http://www.tonepad.com Permission refused for posting from other sites.
OUTPUT