Professional Documents
Culture Documents
Unit Outline TP323 2013
Unit Outline TP323 2013
Unit Coordinator:
Dr. Monica Gumulya 9266 3926 m.gumulya@curtin.edu.au 216 : 305 The best way to contact Dr. Gumulya is via email. Dr. Gumulya will make every effort to respond to email inquiries within 24 hours. Dr. Nina Darmawan nina.darmawan@yahoo.com.au Assoc. Professor Perumal Kumar +60 85 443822 p.kumar@curtin.edu.my
Transport Phenomena 323 July 2013 This unit is managed by Department of Chemical Engineering and Faculty of Science and Engineering
Acknowledgement of Country
We respectfully acknowledge the Indigenous Elders, custodians, their descendants and kin of this land past and present.
Syllabus
Fundamental differential equations of fluid flow phenomena; Development of viscous flow and drag, and effect of fluid flow on mass transfer; Flow with pressure gradient; Friction factor analysis; relationship between fluid flow and heat transfer. Thermodynamics of heat transfer and conductivity of phases based on density/viscosity; Fundamental differential equations of heat transfer; Combination heat transfer and flow dependent heat transfer; Increase of heat transfer by extended surfaces; Unsteady state conduction; Meaning of heat transfer coefficient and analogies between heat and mass transfer; Case studies involving convection; Macroscopic energy balance for heat exchanger capacity. Relationship between mass diffusivity and thermal conductivity; Fundamental differential equations for mass transfer; Boundary conditions and diffusion modelling; Combination of mass transfer with chemical reaction; Convective heat and mass transfer; Laminar flow and turbulent flow mass transfer, and analogies between viscosity, diffusivity and thermal conductivity; Drying combined heat and mass transfer
Introduction
The aim of this unit is to develop a theoretical and practical basis for fundamentals of momentum, heat and mass transports.
Transport Phenomena 323 July 2013 This unit is managed by Department of Chemical Engineering and Faculty of Science and Engineering
project reports Curtins Graduate Attributes Apply discipline knowledge Thinking skills
(use analytical skills to solve problems)
Information skills
(confidence to investigate new ideas)
International perspective
(value the perspectives of others)
Cultural understanding
(value the perspectives of others)
Professional skills
(work independently and as a team) (plan own work)
Find out more about Curtins Graduate attributes at the Office of Teaching & Learning website: otl.curtin.edu.au
______________________________________________________________________________________________________
Transport Phenomena 323 July 2013 This unit is managed by Department of Chemical Engineering and Faculty of Science and Engineering
Referencing style Students should use the Chicago referencing style when preparing assignments. More information can be found on this style from the Library web site: library.curtin.edu.au/research_and_information_skills/referencing
______________________________________________________________________________________________________
Learning Resources
All lecture notes for this unit is available on Blackboard. Recommended texts You do not have to purchase the following textbooks but you may like to refer to them. Bird, R.B., Stewart, W.E. and Lightfoot, E.N. 2006. Transport Phenomena. 2nd ed. John Wiley & Sons. Welty, J., Wicks, C.E., Rorrer, G.L., and Wilson, R.E. 2007. Fundamentals of Momentum, Heat and Mass Transfer. 7th ed. John Wiley & Sons. Incropera, F.P., DeWitt, D.P., Bergman, T.L., and Lavine, A.S. 2006. Fundamentals of Heat and Mass Transfer. 6th ed. John Wiley & Sons.
Transport Phenomena 323 July 2013 This unit is managed by Department of Chemical Engineering and Faculty of Science and Engineering Page 4 of 10 CRICOS Provider Code WA 00301J, NSW 02637B
______________________________________________________________________________________________________
Assessment
Assessment schedule Task
Mid-semester test (1 hr during lecture) Group project
Value (%)
Date due
15% 35%
Final Examination
50
1,2,3
Detailed information on assessment tasks 1. Tests and final examination for this unit will be closed book. A final exam will be held at the end of the semester and will encompass study material, tutorial questions and in-class problem discussions. For the final examination, students are encouraged to bring ONE (1) A-4 sheet (single-sided text), either hand-written or typed, of useful formula, constants and relationships as necessary. ONLY HP10S Calculator to be used during all examinations. Detailed assessment criteria will be announced later. 2. One project assignment with 3 - 4 problems on transport phenomena will be assigned to groups of 4 students. Assignments will be posted on the class web site on week 6. The project will be discussed in the class and feedback will be provided for continuous improvement. In submitting the project, make sure it is typed, all pages numbered, and the assignment of assumptions and parameters, (iii) a clear explanation of the steps/calculations involved in reaching the solution. Also, be sure to indicate appropriate units, as necessary. Assignment/Project report submission The tasks required for the project should be divided between all members of the team. Each team member is required to write up their section (or questions) and all sections combined into the final, composite report. This report should include an executive summary, conclusions, and recommendations.
Transport Phenomena 323 July 2013 This unit is managed by Department of Chemical Engineering and Faculty of Science and Engineering
Fair assessment through moderation Moderation describes a quality assurance process to ensure that assessments are appropriate to the learning outcomes, and that student work is evaluated consistently by assessors. Minimum standards for the moderation of assessment are described in the Assessment Manual, available from policies.curtin.edu.au/policies/teachingandlearning.cfm
Late assessment policy Late submission of assignments will be penalised by 10% of the marked score per calendar day for a late assessment submission. An assessment more than seven working days overdue will not be marked. Work submitted after this time (due date plus seven days) may result in a Fail Incomplete (F-IN) grade being awarded for the unit.
Assessment extension A student must apply for an assessment extension on the form prescribed by the Academic Registrar which can be found at: http://students.curtin.edu.au/administration/documents/Application_forAssessmentExtension. pdf The student will be expected to lodge the form and supporting documentation with the unit coordinator before the assessment date/time or due date/time. An application may be accepted up to five working days after the date or due date of the assessment task where the student is able to provide an acceptable explanation as to why he or she was not able to submit the application prior to the assessment date. An application for an assessment extension will not be accepted after the date of the Board of Examiners meeting.
Pass requirements To pass this unit you must achieve a grade/mark greater than or equal to 5/50.
Plagiarism Academic honesty is crucial to a students credibility and self-esteem, and ultimately reflects on the values and morals of the University as a whole. A student may work together with one or a group of students discussing assignment content, identifying relevant references, and debating issues relevant to the subject. Plagiarism occurs when work or property of another person is presented as one's own, without appropriate acknowledgement or referencing.
Transport Phenomena 323 July 2013 This unit is managed by Department of Chemical Engineering and Faculty of Science and Engineering Page 6 of 10 CRICOS Provider Code WA 00301J, NSW 02637B
Additional Information
Enrolment It is your responsibility to ensure that your enrolment is correct - you can check your enrolment through the eStudent option on OASIS, where you can also print an Enrolment Advice. Supplementary/deferred exams Supplementary and deferred examinations granted by Department of Chemical Engineering will be held between 19-21 February 2014. Notification to students will be made after the Department of Chemical Engineering Board of Examiners meeting via the Official Communications Channel (OCC) in OASIS. It is the students responsibility to check their OASIS account on a weekly basis for official Curtin correspondence. If your results show that you have been awarded a supplementary or deferred exam you should immediately check your OASIS email for details.
______________________________________________________________________________________________________
Information on all these things is available through the Universitys Student Rights and Responsibilities website at: students.curtin.edu.au/rights. Student appeals: http://students.curtin.edu.au/rights/appeals/index.cfm
Student Equity
There are a number of factors that might disadvantage some students from participating in their studies or assessments to the best of their ability, under standard conditions. These factors may include a disability or medical condition (e.g. mental illness, chronic illness, physical or sensory disability, learning disability), significant family responsibilities, pregnancy, religious practices, living in a remote location or another reason. If you believe you may be unfairly disadvantaged on these or other grounds please speak to the Student
Transport Phenomena 323 July 2013 This unit is managed by Department of Chemical Engineering and Faculty of Science and Engineering Page 7 of 10 CRICOS Provider Code WA 00301J, NSW 02637B
http://evaluate.curtin.edu.au/info/dates.cfm
Transport Phenomena 323 July 2013 This unit is managed by Department of Chemical Engineering and Faculty of Science and Engineering
Program Calendar
Week Orientation 1. Begin Date
29 July 5 August
Lecture 1
Lecture 2
Tutorial
Assessment Due
2.
12 August
3.
19 August
4.
26 August
Microscopic analysis (Shell Momentum Balances) Turbulent flows; Interphase Transport (Friction factors, drag) Macroscopic momentum (and mechanical energy) balance
Introduction to Transport Phenomena; Viscosity; Microscopic analysis (Shell momentum balance) Microscopic analysis: (Equations of continuity and momentum) Macroscopic momentum balance
No Tutorial Class
Tutorial 1
Tutorial 2
Tutorial 3
5. 6.
2 September 9 September
7.
16 September
Conductivity and the mechanisms of heat transport Microscopic analysis: Shell Heat Balances Macroscopic balance (nonisothermal)
Microscopic analysis: Shell Heat Balances Turbulent energy transport; Interphase energy transport Macroscopic balance (nonisothermal)
Tutorial 4
Tutorial 5
8.
23 September 30 September
Tutorial 6
9.
Transport Phenomena 323 July 2013 This unit is managed by Department of Chemical Engineering and Faculty of Science and Engineering
Week 10.
Begin Date
7 October
Lecture 1
Lecture 2
Tutorial
11.
12.
13.
14.
Diffusivity and the mechanisms of mass transport Diffusivity and 14 October the mechanisms of mass transport (Shell Balance) Convective 21 October mass transfer within one phase and between phases Analogies of 28 October Momentum, Heat and Mass Transports Mock test and 4 November discussion
11 November 18 November 25 November
Diffusivity and the mechanisms of mass transport (Shell Balance) Convective mass transfer within one phase and between phases Macroscopic balances
Tutorial 7
Tutorial 8
Tutorial 9
Tutorial 10
15. 16. 17
Transport Phenomena 323 July 2013 This unit is managed by Department of Chemical Engineering and Faculty of Science and Engineering