Camera Stabilizer Plans
An instructional manual on how to
build a full stabilizer rig
by
Cody DeeganTable of Contents
Tools Needed 5
Introduction 6
Building the Sled 8
Building the Arm 31
Building the Front-Mount Vest 48
Setting up the Stabilizer 59
Extension Spring Chart 60
How to Balance 6r
Checking Z-axis tilt 65
Checking X-axis tilt 66
Building a Low-Angle Bracket 67
Building a Balancing Stand 71
Safety Tips 73
Building the Back-Mount Vest 77CII Da aa
Tools Needed
Ruler with measurements in 16ths
Flexible measuring tape
Power hand drill
Drill press*
Drill press vise*
Chop saw*
3/8”, 7/16”, 1/2” wrenches and/or sockets
allen wrenches
Phillips screwdriver
Centerpunch
Metal file
55/64”, 27/32”, 1/2”, 5/16”, 1/4”, 3/16” drill bits
10-24 tap and matching #25 drill bit
1/4-20 tap and matching #7 drill bit
5/16-18 tap and matching 17/64” drill bit
3/8-16 tap
T-handle tap wrenches
1/2” rotary file
2” x 1” 60 grit flap wheel
bubble level
hammer
pencil
C-clamps
Rattail file
45-45-90 triangle
Dremel tool (optional)
* Alocal maul sp ean do all tb euting and ding, a well asthe 2 welds sd. Measure eve
ing ot beforehand and mark ial leary, The es work
sop has do,