Professional Documents
Culture Documents
TOROIDAL TRANSFORMERS To be used with ELR-B, ELR-3C and D30 relays. The transformer and relay assembly sensitivity is fixed by the relay. The toroidal transformer CTD-1/28 is specifically designed for DIN rail mounting. Working principles: The toroidal transformer is installed between the source and the load. The system works on the current balance principle. In a correct installation the vector sum of the currents is zero and the relay will not trip. In case of an insulation fault on the circuit a leakage current flows to earth. Now the vector sum of the current passing through the transformer is not zero, this imbalance is detected by the transformer, which induces a current in the secondary winding which is connected to the relay. If the fault level is higher than the selected sensitivity, and when the trip time delay has elapsed, the relay trips and actuates on the shunt trip of a circuit breaker or the coil of a contactor interrupting the supply to the load. The dimensioning of the toroidal transformer depends on the diameter of all active wires (not earth conductors) put through the transformers.
Type CTD-1/28 CT-1/35 CT-1/60 CT-1/80 CT-1/110 CT-1/160 CT-1/210 CTA-1/110 CTA-1/160 CTA-1/210 Code 41055 41060 41065 41070 41075 41080 41085 41076 41081 41086 Inner 28 mm 35 mm 60 mm 80 mm 110 mm 160 mm 210 mm 110 mm 160 mm 210 mm Weight (kg) 0,2 0,2 0,3 0,5 0,5 1,4 1,5 0,5 1,4 1,5
CT-1
CTD-1
53
65
Closed core
Openable core
86
45
44 58
28
Core CT-1/35 CT-1/60 CT-1/80 CT-1/110 CT-1/160 CT-1/210 CTA-1/60 CTA-1/110 CTA-1/160 CTA-1/210 Closed Closed Closed Closed Closed Closed Open Open Open Open
e 100 125 146 178 275 325 140 235 275 325
f 45 70 75 75
i 28 28 28 28 45 45 34 40 45 45
www.fanox.com
fanox@fanox.com 50
10/2010/D00