You are on page 1of 0

1

1
1
4
2
2
3
5
8
10
11
12
10
9
8, 9
5, 6
2, 3
1
4
7
7
6
1 + 2 + 3 + 4
11, 12
Colosseum, Italy: Assembly Instructions
Canon is a registered trademark of Canon Inc. Canon Inc. Y.Watanabe
Assembly Instructions
Mountain fold(dotted line)
Make a mountain fold.
Valley fold(dashed and dotted line)
Make a valley fold.
Scissors line(solid line)
Cut along the line.
Cut in line(solid line)
Cut along the line.

Glue spot(Red dot)
Glue parts with the same number together.
Glue spot(Green dot)
Glue within the same part.
Glue spot(Blue dot)
Glue to the rear of the other part.
Glue
The glue spot(colored dot)
shows where to apply the glue.
Tools and materials
Assembly tip
Caution
Scissors, set square, glue(We recommend stick glue), pencil, used
ballpoint pen, toothpicks, tweezers, (useful for handling small parts)
Before gluing, crease the paper along mountain fold and valley
fold lines and make sure rounded sections are nice and stiff.
Glue, scissors and other tools may be dangerous to young children
so be sure to keep them out of the reach of young children.
View of completed model
Assembly Instructions:Two A4 sheets(No.1 to No.2)
*This model was designed for Papercraft and may differ from the original in some respects.
*Hint: Trace along the folds with a ruler
and an exhausted pen (no ink) to get a sharper, easier fold.
*Build the model by carefully reading the Assembly Instructions, in the parts sheet page order.
Indicates where sections
should be glued together.
Before starting assembly:Writing the number of each section on its
back side before cutting out the sections is highly recommended.
(* This way, you can be sure which section is which even after cutting out
the sections.)
When gluing parts 1 and 2 together,
align the triangles on the ends of part 1 to
the seams on part 2.
Top
Bottom
Fold outward
Fold inward
The illustration below is a close-up of
parts 2, 3, 5, 6, 8, and 9.Be sure to
fold the top and bottom parts correctly.
http://www.canon.com/c-park/en/
2
13, 14
15, 16
14
13
18 17
15
16
23
24
21 19
22
20
Canon is a registered trademark of Canon Inc. Canon Inc. Y.Watanabe
Parts 1 - 12
Parts 17 + 18
Stand
Glue parts 19 and 20 along the top
of parts 21 - 22.
Glue the 16 glue tabs on parts 19 - 24
to the oval on the stand.
When gluing parts 19 - 24 to the stand,
be sure the seams of all parts line up as
shown in the illustration.
Finished!
Parts 19 - 24
Colosseum, Italy: Assembly Instructions

You might also like