You are on page 1of 1

1) EFIS symbol generator a) processes the info and sends input to pilot ......

.dnt exactly remember the options . 2) EFIS distributes information via a) digital signal , b) analogue signal , c)carrier wave , d)none of the above . 3) Stall stip use a) provide lift at slow speeds b) lift at low angle of attacks c) promote root stalling first ..... d ) .... 4) Engine primary instrument a) tachometer , b) torque meter , c) airspeed indicator , d).... 5) Differential system is associated with which system a) aileron , b) rudder , c) elevator, ..... 6) Pitostatic system connected to 1) vsi 2) altimeter 3) cabin altimeter 4) airspeed indicater 5) ......dnt remebr. a) 1,2,4 b) 1,2,3,4,5 c) 1,2,3 d) 7) D.c current conneted to a battery in series .- . a) current will remain the same , b) voltage will remain the same .... dnt remember 8) ( q 21 in the exam paper. ) if any of the flag HDG , NAV , GS appear in the .H.S.I - a) equip inoperative , b) equipment operative , c) only that particular equip operative .. .d) ..... 9) Ohms law. 10) Take off warning a) squat switch ,b) landing gear retract switch , c) throttle idle .....something .... d ) .... 11) Order of a gas turbine a) intake ,reverse thrust , compression , combustion b) intake , compression , combustion , expansion thru trubine , exahaust . ................. 12) Order of piston engine cycle13) What happens to the velocity of air in the throat of a convergent divergent duct of a nozzle ( propelling nozzle i think not sure ) ... a) increases . b) decreases .......... 14) Why is A.C current used in aircraft ? a) more effecient b) can be easily regulated with a regulator , c) can be easily controlled with an ammeter . ................ 15) Red line in an Oil temperature gauge indicates a) minimum safe operating range , b) minimum and /or maximum safe operating range , c) minimum precautionary operating range ,d) minimum operating range . ( doubtful abt the d option ) .... 16) Stall warning occurs when a) stall is imminent ,..... 17) Bourdon tube is used to indicate 1) pressure 2) temperature 3) position 4) ... a)1,2 b) 1,3 c) 2,3. 18) sources of electrical energy 1) magnetic , chemical ,..... 2) pressure 3) thermal 4) all of the above . 19) in a turn the stalling speed depends on 1) load factor , 2) weight , 3) ..... 4) .......... a) 1,2 b) 1,2,3 ..........

You might also like