Professional Documents
Culture Documents
2003تصميم حمامات السباحه
2003تصميم حمامات السباحه
.8 1.20
1.5
2
1.25 2
1.80 2
3.60 2
1.35 2
2.25 2
4 2
2.25 2
15.75 2
2.70 2
18.00 2
-:
) (air gap
-:
-1 floor inlet
-2 wall inlet
20 3
25 2
6
4.5 0.6/ 2.40
3.60 6
-:
3
8
-:
-1
-2
-3
-4
-5
-6
-7
)(surge tank
)(inlet
)(out let
)(over flow
)(pump
-:
8
1.5/ 2.00/
1
0.60 / ) 0.15 / (
1.00 / ) 0.15 / (
2.30 / ) 0.15 / (
3.80 / ) 0.15 / (
6.00 / ) 0.15 / (
10 / ) 0.15 / (
20 / ) 0.15 / (
40 / ) 0.15 / (
-:
)(heat exchanger
-:
2
24 30 28
96 48
37
:SWIMMING POOL TYPES
Commercial Pools - Municipal, community, leisure and club, senior schools, hotels,
large
Apartment, multiple housing units, pools ancillary to club
,facilities
(High or medium bathing loads)
Competition pools International, national and regional swimming contest
(moderate
Bathing Loads) generally full Olympic 50m x 25m or half
-Olympic
25m x 13m
(Teaching Pools -
Treatment Pools - Special therapeutic and hydrotherapeutic, spa and hot tub (high
bathing
(Loads with special problems
Paddling Pools Very shallow or shelving waters for children (very high bathing
load
Presenting special problems
(Diving Pools
Domestic Pools Garden or indoor, above ground and in ground (low bathing
loads
(Such as owner, family and guest only
Equine Pools Pools for exercise and hydrotherapy of horses, usually round
with either
One or two slope access ramps with Central Island. Because
of the
usage, the Maximum depth is 3m. The ramp should be padded
with
rubber flooring And sheeting to protect the animal and the
internal
finish is usually painted Due to the risk of damage from
hooves.
Filtration is medium rate with Large Filter bed area. It is
advisable to
increase the size to surface Skimmer basket in order to catch
hay /straw
etc...Pool water heating, if Required, is as normal. Treatment
control
system is to be encouraged.
Filtration and treatment systems must be oversized. Specific
requirements May need to be addressed but generally water
depths
should fall to approx From the ramp. Temp should be within
the range
of 65 - 75F.
Canine Pools Construction are typical to equine pools but much smaller.
Access
Ramps are not necessary. Heated water is much more likely
and the risk
.Of Faucal contamination is almost nil
TYPE OF POOL
(OVER PERIOD (HRS
TURN
2 25 ........................... -1
4
= .................... 3.6 = 90/25 4
-2 .........................
2.40 3.60 6.
-3 turn over period .3
-4 Pump Capacity = V / (turn over period * 60
(
= .m3 / min 0.75 = (60*3) /135
= .m3 / hr 45
-5 22.5 =45/2 /3
-6
22.5 /3 high rate sand filter
) 15 / / ( 2 ) 35 /3 / ( 2
15 / / 2
20 / / 2
V2
V2
V2
: : 4 4 45 / 3
11.25 = 45/4 / 3
Supply velocity (max 2 m/s)... dia (mm) = V2 x 13.3
Dia = 11.25 X 13.3 = 44.6 mm .say 50 mm
Dia = 22.50 X 13.3 = 63.0 mm .say 65 mm
Dia = 33.75 X 13.3 = 77.3 mm .say 80 mm
Dia = 45.00 X 13.3 = 89.2 mm .say 100 mm
: : 2 2 4 45 / 3
Suction velocity (max 1.2m/s) dia (mm) = V2 x 17
Dia = 22.50 X 17.0 = 80.63 mm .say 80 mm
Dia = 45.00 X 17.0 = 114.0 mm .say 110 mm
: : 6 4.5
6
Grille velocity (max 0.3m/s) dia (mm) = V2 x 18.5
Dia = 7.50 X 18.50 = 50.7 mm .say 50 mm
Dia = 15.0 X 18.50 = 71.7 mm .say 80 mm
5
-: -9
Pool System Circulating Rate / filter velocity
22.5 (m3 / hr ) / 35 (m3 / hr / m2) = 0.64 m2
2 0.64 = 2 / / 15 / 3 22.5 -: -10
Btu/min 11,874 =
Btu/hr 712,443.6 =
TR 36.58 =
:CFM required to reject the heat
cfm /gpm x 198 gpm 51.25 =
CFM 10,147.5 =
:Therefore the Heat pump (chiller/heater) capacity will be
Duty cooling: 712.443 MBH @ 10,147.5 CFM, @115/86C
ambient
Duty heating: 19.60 KW @ 10/6 C ambient
-: -12
For drain exit :
Q =198 gpm @ 50% maindrain= 99 gpm , main drain selection, 49.5 gpm @3.2
,fps
/ 49.5 / 56
[V (m/s) = circulation rate (m3 /hr) /[ free open area of grille m2*3600
m/s 0.25 = [ 3600 * 4 / 2 18 .0 * 3.14 ] / 22.5=
since maindrain shall not be more than 0.5 m / sec /// selection is ok
For guilter exit :
Q = 198 gpm@ 50% gutter drain- 99 gpm - gutter drain select : 16.5 gpm each
for 6 no.
gpm
-: -13
12345-