Professional Documents
Culture Documents
4M:2011
Welder_______________________________________
Welding Process:
SMAW
FCAW-G
FCAW-S
GMAW
Figure 6.5(A)
Figure 6.5(B)
Figure 6.5(C)
Direct Butt
Figure 6.5(D)
Position ________________________
Groove Type_____________________
Backing:
Yes
No
Backgouging:
Yes
No
Technique:
Stringers
Indirect Butt
Single Bevel
T-Joint
Double Bevel
ELECTRICAL CHARACTERISTICS
Current:
AC
DCEP
DCEN
Short-circuiting
BASE METAL
welded to
Globular
Spray
Material Specification______________
Grade _______________________
Material Specification______________
Grade _______________________
Coated Bar:
Yes
No
FILLER METAL
AWS Specification______________________________
Single
Mixture
Composition_____________________
PREHEAT/INTERPASS
Preheat/Interpass Temperature (Min) _______________
Interpass Temperature (Max) _____________________
WELDING PARAMETERS
Pass
Number
Electrode
Diameter
Type
Current
WFS
Amperage ipm [mm/min.]
54
Volts
Electrical
Stickout
Travel
Speed
(ipm)
Joint
Detail
AWS D1.4/D1.4M:2011
Pass
Comments____________________________________
Comments ____________________________________
____________________________________________
_____________________________________________
_______________________________________________________________________________________________
TENSILE TEST
Test Assembly Number Two
Specimen No.
Width
Thickness
Pass
Area
Ultimate
Tensile Load
(lbs)
Ultimate
Unit Stress
(psi)
Character of
Failure and
Location
MACROETCH TEST
Test Assembly Number Two
Pass
Results
Remarks
We, the undersigned, certify that the statements in this record are correct and that the welds were prepared and tested in
accordance with the requirements of AWS D1.4/D1.4M:2011, Structural Welding CodeReinforcing Steel.
Manufacturer or Contractor __________________________________________________________________________
Authorized by _______________________________________________________
Form A-1 (back)
55
Date ___________________