Professional Documents
Culture Documents
30002
R1 10K R2 1K
T1 3 5 3
290VAC
4
R3 68K L1 CHOKE
6X5
C1A 20uF
18M = Band 1 1M8 = Band 2 180K = Band 3 18K = Band 4 AMPLITUDE CONTROL 0 - 50V p-p
R4 50K 2 220nF 3 1
6K6A
C1B 20uF
8 5
34000
+ 2 7 C3 8uF C2A 20uF + R9 100K 8 R10 5K 3 R5 18M R6 1M8 R7 180K R8 18K
C4
4 5 C5 R11 1M 2 7 8 +
NOTES: R4 should be precision high quality pot brand Allen Bradley or Clarastat, not carbon track C4 and C10 should be paper or mylar, NOT electrolytic R13, R20, R29 and R30 are wirewound C7 is compression mica trimmer C8 is tubular ceramic, measured at 52pf - probably should be 50pF nominal. Lamp F1 is a General Electric 3S6, 3 Watt 120v. Only this bulb will work, there is no known substitute.
290VAC
2
6SJ7
6.3 VAC
7 XFRMR F1 LAMP
6 4 5 C8 52pF 7 2 R15 18K R16 180K R17 1M8 R18 18M SW1 4 WAY ROTARY C7 62pF HTR SUPPLY
R14 47K
Set to 34.4 pF
C6 29-460pF
R13 1K8 7W
HTR SUPPLY
TUNING DIAL
R19 15K
Resistors should be 3W unless otherwise specified. Filter choke L1 is unknown but is probably 5-8 Henries. Suitable part is Merit Transformer Company part number C-2995, 8.0 henry, 100ma, DC resistance 375 ohms, volts insulation 1500
4
R20 10K
15W
C9 500nF
R21 10K
R22 3K3
6SN7 6K6B
R23 330R C10 8uF 1 3
R24 470K
Transformer T1 was measured at 290V, windings are probably 280V actual nominal rating.
C2B 20uF
1235V @ 200mA
2 V6 866A
V7 PHANOTRON L4
T2 T3 1 V8 866A
C13 6nF
C14
F2 5A F3 3A
FIL XFRMR
TANK COIL
L5 40T 2.5"
160pF
812A
TANK COIL DIMENSIONS DIAMETER 6.7 cm INTERWINDING SPACING 3mm LENGTH 11.5cm WIRE GAUGE 16 swg TOTAL TURNS 40 TAP @ TURN 17
L6 2 SW2 OSC+HTRS 1 2
C16 250pF 3
SW3 HT 1
1mH T4 J1
75W Rheostat
1 2 3 2 R29 10K 1 1 C17 4
HEATER XFRMR
6.3V @ 6A
JACK SOCKET
6nF
1 JACK SOCKET
110V AC LINE 1 2
75W Rheostat Drawn By: Aubrey Scoon. Analysis and corrections by Robert Harrison
BEAM RAY MACHINE Document Number <Doc> Thursday, April 04, 2002
1
Rev A Sheet 1 of 3