BREEZE-EASTERN
CORPORATION ‘rp-01-002
Rev. A
FLIGHT LINE OPERATION AND ‘MAINTENANCE MANUAL
HS-29700 SERIES RESCUE HOIST SYSTEM.
TO: HOLDERS OF BREEZE-EASTERN FLIGHT LINE OPERATION AND MAINTENANCE
MANUAL FOR HS-29700 SERIES RESCUE HOIST SYSTEMS, TD-01-002
REVISION H OF TD-01-002, DATED SEPTEMBER 19, 2008 IS RELEASED.
HIGHLIGHTS
Revision H, dated September 19, 2008, replaces Revision G, dated March 3, 2008 in its entirety. Please
replace Revision G with the new manual provided. Indicate on the Record of Revisions the date of this
action, as well as the initials of the individual performing this task.
SECTION, PAGE, DESCRIPTION OF CHANGE
All Added standard format into manual, which include, but are not limited to the following:
Alll applicable sections, page dates change to September 19, 2008.
Reviewed all possible TPDR’s, ASB’s, SB’s, SIL’s and change orders for possible
applicability.
Revised List of Effective Pages and Table Of Contents to reflect changes as required.
Description and Operation Section - Added HS-29700-217 Rescue Hoist System
Configuration to the manual. Added the -217 Configuration to, Table 1, “System
Configuration Matrix,” Page 2.
Section 201, Added the HS-29700-217 reference to Paragraph 1 “General” statement.
Added Figure 209 Wiring Diagram for HS-29700-217, Rescue Hoist System and added
pages 209 and 210 (Blank).
Section 501, revised beginning paragraph to emphasize that Checks and Inspection are
applicable when the Rescue Hoist is installed on the helicopter e.g. not while being
stored, transported, processed, etc.
Table 501, Page 502, revised last row recommended inspection frequency to 6 months /
400 flight hours / 100 hoist cycles. Same Table 501, Page 502 second to last row changed
200 hoist cycles to 100 hoist cycles for levelwind and cable guide shaft to be consistent
with 100 hoist cycle standard.
Section 1001, Page 1005, Added reference to the HS-29700-217 Rescue Hoist System
Configuration (Added -18, Effectivity Code U) to the Illustrated Parts List.
HIGHLIGHTS
Page H-1
September 19, 2008BREEZE-EASTERN
CORPORATION To-o-02
FLIGHT LINE
OPERATION AND MAINTENANCE MANUAL
With
Illustrated Parts List
HS-29700 Series Rescue Hoist Systems
SAFETY WARNING
For your own safety and the safety ofall others, eed and understand all of the procedures and information inthis operation and maintenance manual
before installing, operating and / oF maintaining any components of the rescue hoist systems covered herein
EXPORT CONTROLLED - WARNING
This document may contain information that is subject to the Intemational Trafic in Arms Regulations (ITAR) or the Export Administration
Regulations (EAR), and may not be exported, released, or disclosed to foreign nationals, either in the United States or overseas, without ist complying
‘with the export requirements / regulations of the ITAR and / or EAR. The recipient is responsible for complying with all such export requirements /
‘regulations. Include this notice with any reproduced portions ofthis document.
NOTICE
‘This manual contains BREEZE-EASTERN CORPORATION, proprietary data that shall not be duplicated, used, of disclosed - in whole or in part = for
any purpose other than fo evaluate this submittal by the recipient and is subject to retura upon request. The recipient shall have the right 1 duplicate,
use or disclose the data tothe extent provided in the contract. This restiction does not limit the recipients right to use information contained ia this
data if tis properly obtained from another source without restriction,
25-61-00
Page T-1
September 19, 2008