Professional Documents
Culture Documents
TL-MR3020 User Guide
TL-MR3020 User Guide
FCC STATEMENT
This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures: Reorient or relocate the receiving antenna. Increase the separation between the equipment and receiver. Connect the equipment into an outlet on a circuit different from that to which the receiver is connected. Consult the dealer or an experienced radio/ TV technician for help.
This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: 1) This device may not cause harmful interference. 2) This device must accept any interference received, including interference that may cause undesired operation. Any changes or modifications not expressly approved by the party responsible for compliance could void the users authority to operate the equipment. Note: The manufacturer is not responsible for any radio or tv interference caused by unauthorized modifications to this equipment. Such modifications could void the users authority to operate the equipment.
CE Mark Warning
This is a class B product. In a domestic environment, this product may cause radio interference, in which case the user may be required to take adequate measures.
National restrictions
This device is intended for home and office use in all EU countries (and other countries following the EU directive 1999/5/EC) without any limitation except for the countries mentioned below: Country Restriction Reason/remark
General authorization required for outdoor use and public service Military Radiolocation use. Refarming of the 2.4 GHz band has been ongoing in recent years to allow current relaxed regulation. Full implementation planned 2012 If used outside of own premises, general authorization is required General authorization required for network and service supply(not for spectrum) This subsection does not apply for the geographical area within a radius of 20 km from the centre of Ny-lesund Only for indoor applications
Bulgaria
None
Outdoor use limited to 10 France mW e.i.r.p. within the band 2454-2483.5 MHz
Italy
None
Luxembourg
None
Norway
Implemented
Russian Federation
None
II
NCC Notice:
III
DECLARATION OF CONFORMITY
For the following equipment: Product Description: Portable 3G/3.75G Wireless N Router Model No.: TL-MR3020 Trademark: TP-LINK We declare under our own responsibility that the above products satisfy all the technical regulations applicable to the product within the scope of Council Directives: Directives 1999/5/EC The above product is in conformity with the following standards or other normative documents ETSI EN 300 328 V1.7.1: 2006 ETSI EN 301 489-1 V1.8.1:2008& ETSI EN 301 489-17 V2.1.1:2009 EN60950-1:2006 Recommendation 1999/519/EC EN62311:2008 Directives 2004/108/EC The above product is in conformity with the following standards or other normative documents EN 55022:2006 +A1:2007 EN 55024:1998+A1:2001+A2:2003 EN 61000-3-2:2006 EN 61000-3-3:1995+A1:2001+A2:2005 Directives 2006/95/EC The above product is in conformity with the following standards or other normative documents EN60950-1:2006 DirectiveErP 2009/125/EC Audio/Video, information conscious design EN62075:2008 Person is responsible for marking this declaration: and communication technology equipmentEnvironmentally
TP-LINK TECHNOLOGIES CO., LTD. Building 24 (floors 1, 3, 4, 5), and 28 (floors 1-4) Central Science and Technology Park, Shennan Rd, Nanshan, Shenzhen, China
CONTENTS
Package Contents .......................................................................................................................... 1 Chapter 1. Introduction................................................................................................................. 2 1.1 1.2 1.3 1.4 Overview of the Router................................................................................................. 2 Conventions ................................................................................................................. 2 Main Features .............................................................................................................. 3 Panel Layout ................................................................................................................ 4 1.4.1 1.4.2 The Front Panel................................................................................................ 4 The Rear Panel ................................................................................................ 5
Chapter 2. Connecting the Router ............................................................................................... 6 2.1 2.2 2.3 System Requirements .................................................................................................. 6 Installation Environment Requirements ........................................................................ 6 Connecting the Router ................................................................................................. 6
Chapter 3. Quick Installation Guide........................................................................................... 10 3.1 3G Router Mode......................................................................................................... 10 3.1.1 3.1.2 3.1.3 3.2 PC configuration ............................................................................................. 10 Connect to Network ........................................................................................ 10 Router Configuration....................................................................................... 10
WISP Mode ................................................................................................................ 14 3.2.1 3.2.2 3.2.3 PC configuration ............................................................................................. 14 Connect to Network ........................................................................................ 14 Router Configuration....................................................................................... 15
3.3
AP Mode .................................................................................................................... 19 3.3.1 3.3.2 3.3.3 PC configuration ............................................................................................. 19 Connect to Network ........................................................................................ 19 Router Configuration....................................................................................... 20
Chapter 4. Router Configuration3G Router Mode ................................................................ 27 4.1 4.2 4.3 4.4 4.5 Login .......................................................................................................................... 27 Status ......................................................................................................................... 27 Quick Setup................................................................................................................ 28 WPS ........................................................................................................................... 28 Network ...................................................................................................................... 36 4.5.1 4.5.2 4.5.3 Internet Access ............................................................................................... 36 3G................................................................................................................... 37 WAN ............................................................................................................... 42
I
Wireless ..................................................................................................................... 53 4.6.1 4.6.2 4.6.3 4.6.4 4.6.5 Wireless Settings ............................................................................................ 53 Wireless Security............................................................................................ 56 Wireless MAC Filtering ................................................................................... 59 Wireless Advanced ......................................................................................... 61 Wireless Statistics........................................................................................... 62
4.7
DHCP ......................................................................................................................... 63 4.7.1 4.7.2 4.7.3 DHCP Settings ............................................................................................... 63 DHCP Clients List ........................................................................................... 65 Address Reservation ...................................................................................... 65
4.8
Forwarding ................................................................................................................. 66 4.8.1 4.8.2 4.8.3 4.8.4 Virtual Servers ................................................................................................ 67 Port Triggering ................................................................................................ 68 DMZ................................................................................................................ 70 UPnP .............................................................................................................. 71
4.9
Security ...................................................................................................................... 72 4.9.1 4.9.2 4.9.3 4.9.4 Basic Security................................................................................................. 72 Advanced Security.......................................................................................... 74 Local Management ......................................................................................... 75 Remote Management ..................................................................................... 76
4.10 Parental Control ......................................................................................................... 77 4.11 Access Control ........................................................................................................... 80 4.11.1 Rule ................................................................................................................ 80 4.11.2 Host ................................................................................................................ 86 4.11.3 Target.............................................................................................................. 88 4.11.4 Schedule......................................................................................................... 90 4.12 Advanced Routing ...................................................................................................... 91 4.12.1 Static Routing List ........................................................................................... 92 4.12.2 System Routing Table..................................................................................... 93 4.13 Bandwidth Control ...................................................................................................... 93 4.13.1 Control Settings .............................................................................................. 94 4.13.2 Rules List........................................................................................................ 94 4.14 IP & MAC Binding....................................................................................................... 95 4.14.1 Binding Settings.............................................................................................. 95 4.14.2 ARP List.......................................................................................................... 97
II
4.15 Dynamic DNS............................................................................................................. 98 4.15.1 Comexe.cn DDNS .......................................................................................... 98 4.15.2 Dyndns.org DDNS .......................................................................................... 99 4.15.3 No-ip.com DDNS .......................................................................................... 100 4.16 System Tools ............................................................................................................ 101 4.16.1 Time Settings................................................................................................ 102 4.16.2 Diagnostic..................................................................................................... 103 4.16.3 Firmware Upgrade ........................................................................................ 105 4.16.4 Factory Defaults ........................................................................................... 106 4.16.5 Backup & Restore......................................................................................... 106 4.16.6 Reboot .......................................................................................................... 107 4.16.7 Password...................................................................................................... 108 4.16.8 System Log................................................................................................... 108 4.16.9 Working Mode .............................................................................................. 109 4.16.10 Statistics ....................................................................................................110
Chapter 5. Router ConfigurationWISP Mode .......................................................................112 5.1 5.2 5.3 5.4 5.5 Login .........................................................................................................................112 Status ........................................................................................................................112 Quick Setup...............................................................................................................113 WPS ..........................................................................................................................113 Network .................................................................................................................... 121 5.5.1 5.5.2 5.5.3 5.6 WAN ............................................................................................................. 121 MAC Clone ................................................................................................... 130 LAN............................................................................................................... 131
Wireless ................................................................................................................... 132 5.6.1 5.6.2 5.6.3 5.6.4 5.6.5 Wireless Settings .......................................................................................... 132 Wireless Security.......................................................................................... 135 Wireless MAC Filtering ................................................................................. 139 Wireless Advanced ....................................................................................... 141 Wireless Statistics......................................................................................... 142
5.7
DHCP ....................................................................................................................... 143 5.7.1 5.7.2 5.7.3 DHCP Settings ............................................................................................. 143 DHCP Clients List ......................................................................................... 145 Address Reservation .................................................................................... 145
5.8
Forwarding ............................................................................................................... 146 5.8.1 5.8.2 Virtual Servers .............................................................................................. 147 Port Triggering .............................................................................................. 148
III
Security .................................................................................................................... 152 5.9.1 5.9.2 5.9.3 5.9.4 Basic Security............................................................................................... 152 Advanced Security........................................................................................ 154 Local Management ....................................................................................... 155 Remote Management ................................................................................... 156
5.10 Parental Control ....................................................................................................... 157 5.11 Access Control ......................................................................................................... 160 5.11.1 Rule .............................................................................................................. 160 5.11.2 Host .............................................................................................................. 166 5.11.3 Target............................................................................................................ 168 5.11.4 Schedule....................................................................................................... 170 5.12 Advanced Routing .................................................................................................... 171 5.12.1 Static Routing List ......................................................................................... 172 5.12.2 System Routing Table................................................................................... 173 5.13 Bandwidth Control .................................................................................................... 173 5.13.1 Control Settings ............................................................................................ 174 5.13.2 Rules List...................................................................................................... 174 5.14 IP & MAC Binding Setting ........................................................................................ 175 5.14.1 Binding Settings............................................................................................ 175 5.14.2 ARP List........................................................................................................ 177 5.15 Dynamic DNS........................................................................................................... 178 5.15.1 Comexe.cn DDNS ........................................................................................ 178 5.15.2 Dyndns.org DDNS ........................................................................................ 179 5.15.3 No-ip.com DDNS .......................................................................................... 180 5.16 System Tools ............................................................................................................ 181 5.16.1 Time Setting.................................................................................................. 182 5.16.2 Diagnostic..................................................................................................... 183 5.16.3 Firmware Upgrade ........................................................................................ 185 5.16.4 Factory Defaults ........................................................................................... 186 5.16.5 Backup & Restore......................................................................................... 186 5.16.6 Reboot .......................................................................................................... 187 5.16.7 Password...................................................................................................... 188 5.16.8 System Log................................................................................................... 188 5.16.9 Working Mode .............................................................................................. 189 5.16.10 Statistics ................................................................................................... 190
IV
Chapter 6. Router ConfigurationAP Mode........................................................................... 192 6.1 6.2 6.3 6.4 6.5 Login ........................................................................................................................ 192 Status ....................................................................................................................... 192 WPS ......................................................................................................................... 194 Network .................................................................................................................... 202 Wireless ................................................................................................................... 203 6.5.1 6.5.2 6.5.3 6.5.4 6.5.5 6.6 Wireless Settings .......................................................................................... 203 Wireless Security...........................................................................................211 Wireless MAC Filtering ................................................................................. 219 Wireless Advanced ....................................................................................... 221 Wireless Statistics......................................................................................... 223
DHCP ....................................................................................................................... 223 6.6.1 6.6.2 6.6.3 DHCP Settings ............................................................................................. 224 DHCP Clients List ......................................................................................... 225 Address Reservation .................................................................................... 226
6.7
System Tools ............................................................................................................ 227 6.7.1 6.7.2 6.7.3 6.7.4 6.7.5 6.7.6 6.7.7 6.7.8 6.7.9 Time Setting.................................................................................................. 227 Diagnostic..................................................................................................... 229 Firmware Upgrade ........................................................................................ 231 Factory Defaults ........................................................................................... 232 Backup & Restore......................................................................................... 232 Reboot .......................................................................................................... 233 Password...................................................................................................... 234 System Log................................................................................................... 234 Working Mode .............................................................................................. 235
6.7.10 Statistics ....................................................................................................... 236 Appendix A: FAQ ........................................................................................................................ 238 Appendix B: Configuring the PCs............................................................................................. 243 Appendix C: Specifications ....................................................................................................... 247 Appendix D: Glossary................................................................................................................ 248 Appendix E: Compatible 3G/3.75G USB Modem ..................................................................... 250
TL-MR3020
Package Contents
The following items should be found in your package: