LAP JOINT
Aim:
To make a Lap joint using are welding ob the given workpieces.
Mild steel plate of size 100 x 50 x 06 mm —2 Nos.
Tools required:
Power supply (AC/DC)
Welding Torch
Electrodes:
Tongs
Chipping harimer
Wire brush
Gloves
Apron
Shield
10, Safety gozeles
11, Earth Clamp
eRe epbeee
Sequence of Operations
Edge preparation (Removal of rust, seale ete.. by fling)
Tackis
Welding
Cooling
Chipping
Cleaning
Pea po
Working Procedure:
1. First ofall, the work pieces must be thoroughly cleaned to remove rust, seale and
other foreign material by filing,
ces are placed on the table in such a way that two work pieces
re
‘Then the work pi
are overlapped ane over another as shown
3. Appropriate power supply should be given to the electrode and the work pieces.
4, When current is passed, is produced between electrode and the work piece.When current is passed, is produced between electrode and the work pieces.
6. Set the two work pieees in correct position like Lap join! and tack a: both ends of
the work pieces as shown in figure.
7. ‘Then the welding is carried owt throughout the length of the wark piece
8. Assounas the welding process's finished switch off the e
rent supply
9. ‘Then allow the work pizce to cool, afer that slags are removed! by
process with the help of chipping hammer.
hipping
10, Finally by using wire brush, welded portions (Weldment) are cleaned.
Results
Thus the desired lap joint is obtained using are welding,
Notes Lap joints are used in fabrication of irom tubes for steam and water pipe3. LAP. JOINT
DRAWING :
* All dimensions are in mm