The aim of this step is to model prevalent power system components. These models will be used in future steps of your project; hence be careful which parameters are used and which assumptions you consider. The recommended model of the study system is shown as below: 1The parameters of Generator, Transformers, Lines, Load and etc should be considered in the modeling. 2All the entered parameters should be actual (real-life) and accurate as reported in the associated documents. 3The references should be attached in each part of modeling. 4The following
The aim of this step is to model prevalent power system components. These models will be used in future steps of your project; hence be careful which parameters are used and which assumptions you consider. The recommended model of the study system is shown as below: 1The parameters of Generator, Transformers, Lines, Load and etc should be considered in the modeling. 2All the entered parameters should be actual (real-life) and accurate as reported in the associated documents. 3The references should be attached in each part of modeling. 4The following
The aim of this step is to model prevalent power system components. These models will be used in future steps of your project; hence be careful which parameters are used and which assumptions you consider. The recommended model of the study system is shown as below: 1The parameters of Generator, Transformers, Lines, Load and etc should be considered in the modeling. 2All the entered parameters should be actual (real-life) and accurate as reported in the associated documents. 3The references should be attached in each part of modeling. 4The following
Step One: Electric Power System Modeling and Analysis
The aim of this step is to model prevalent power system components within Matlab- Simulink environment. It should be noted that, these models will be used in future steps of your project; hence be careful which parameters are used and which assumptions you consider. The recommended model of the study system is shown as below:
1- The parameters of Generator, Transformers, Lines, Load and etc should be considered in the modeling. 2- All the entered parameters should be actual (real-life) and accurate as reported in the associated documents. 3- The references should be attached in each part of modeling. 4- The following parameters should be reported:
, , , , , , , G G G G G Load Load f G out out v I v I I P Q
Dr. H.Lesani Fall 2013 Contact information to ask questions or learn additional information: a.shahsavari@ut.ac.ir