Professional Documents
Culture Documents
Fluke1760 USB Drivers InstallationHowTo
Fluke1760 USB Drivers InstallationHowTo
USB Driver Installation
2
Select USB Virtual Network and press Next.
Choose destination folder and press Next.
1760 / PQ Analyze
USB Driver Installation
3
Select Program Folder and press Next.
On Windows 2000 systems you get the dialog below (please uncheck).
1760 / PQ Analyze
USB Driver Installation
4
Press Finish to complete Setup.
Now plug the USB host to host cable into the USB port of your computer.
Note: Please wait approximately 1 minute. Windows XP needs this time to assign a valid
IP address to the network interface.
Note: Please make sure the "Alternate Configuration" option is set to "automatic" in the
"Internet Protocol (TCP/IP) properties" settings of your USB virtual network adapter.
Plug the other end of the cable into the USB port of your Fluke 1760.
Note: Please watch the LED next to the CF card slot while connecting the USB cable. If
the LED is on then the USB link cable was successfully detected and activated. If the
LED remains dark then please disconnect the cable, wait 3 seconds and try again.
1760 / PQ Analyze
USB Driver Installation
5
Launch PQ Analyze.
Select Transfer>Fluke 1760>Search Devices
Select the USB Virtual Network Adapter and press Search
Connect to your instrument.