Deflecting-arm strain gauges consists of an aluminium strip with two attached strain gauges (SG) the strain gauges are covered with a transparent silicone layer to prevent damage.
Deflecting-arm strain gauges consists of an aluminium strip with two attached strain gauges (SG) the strain gauges are covered with a transparent silicone layer to prevent damage.
Deflecting-arm strain gauges consists of an aluminium strip with two attached strain gauges (SG) the strain gauges are covered with a transparent silicone layer to prevent damage.
The deflecting-arm strain gauges consists of an aluminium strip with two attached strain gauges (SG). The strain gauges are covered with a transparent silicone layer to prevent damage. The deflecting arm is clamped between two plates for mounting on to the MPS
profile. A force is applied at the opposite end of the strip via an
eyelet screw.
A mechanical stop fitted between the MPS
profile and the deflecting arm ensures
that plastic deformation of the sensor does not occur due to excessive loading.
The deflecting-arm strain gauges is calibrated by means of attaching weights from the set.
When a force is applied via the eyelet, the deflecting arm is deflected downwards. The attached strain gauges undergo the same deformation as the deflecting arm, whereby their electrical resistance changes. This effect is transformed into a voltage signal of just a few millivolts via a wheatstone bridge circuit. The signal can be amplified with the measuring bridge amplifier and transmitted to an evaluating device.
The plugs of the connection cable are colour coded as follows :
Deflecting-arm strain gauges In the characteristic curve below, the sensor signal, balanced and amplified by the bridge amplifier, is plotted against the force.
0 1 2 3 F (N) 5 0 0.2 0.4 V (V) Quarter-bridge 0.6 1.0
0 1 2 3 F (N) 5 0 0.2 0.4 V (V) Half-bridge 0.6 1.0
Characteristic curves
Measuring range 0 5 N Overload 130 % of measuring range Operating temperature -10 +70 C SG type Foil SG SG resistance 350 Permissible supply voltage Max. 10 V Material Stop galvanised steel, Deflecting arm Al, Clamping plate Al, anodised Weight 200 g Connection cable 4-wire, shielded, 2 m Connection 4 mm-safety plugs