SYNCHRONOUS DIGITAL HIERARCHY PASOLINK + (STM-1/1+1 SYSTEM) INSTRUCTION MANUAL ROI-S04122-051E 020107 NEC Corporation TOKYO, JAPAN ROI-S04122 CAUTION -1- CAUTION In the case of using at marine and coastal areas (within 3 km from the seaside), it is necessary to make measures against the damage from salt water. For measurements against the damage from salt water to an ODU, request to NEC. CAUTION ROI-S04122 -2- 2 pages (This page is intentionally left blank) ROI-S04122 WARNING -1- WARNING 1. After turning ON the equipment, wait at least 10 seconds before turning it OFF again. Repeatedly turning the power ON and OFF with in a short interval may cause the I DU to fail. 2. The 43 V DC power is superimposed on the center conductor of the coaxial cable between the I DU and the ODU. Connecting a test set equipment directly to this terminal may damage it and touching the coaxial cable core may cause electrical shock. 3. Persons performing servicing must take necessary steps to avoid electro-static discharge which may damage the modules on the I DU or cause error. Wear a conductive wrist strap connected to the grounded (G) jack on the front of the equipment shelf. This will minimize static build-up during servicing. 4. Do not disconnect I F cable between the I DU and the ODU in operating condition, to avoid damaging the I DU and ODU. Do not remove/connect the I F cable with I DU power ON, turn I DU power OFF before remounting the I F cable. WARNING ROI-S04122 -2- 2 Pages (This page is intentionally left blank) ROI-S04122 PREFACE -1- PREFACE This instruction manual has been prepared to provide descriptive and procedural information on the PASOLINK + equipment used in the point- to-point digital microwave radio system for the synchronous digital hierarchy (SDH) in 1 +1 configuration. Included are: Safety Information ROI-S03950-052E Safety Information Abbreviation ROI-S03261-056E Abbreviations Section I ROI-S03895-057E Description ROI-S04077-052E Appendix Radio Frequency Plan for Pasolink + Section II ROI-S03896-056E Operation Section III ROI-S03897-056E Installation and Initial Lineup Section IV ROI-S03898-055E Maintenance PREFACE ROI-S04122 -2- 2 Pages (This page is intentionally left blank.)