Install split jambs by fastening each to the front edge of split studs using 8d finish nails, maintaining a 3/16" clearance on both sides of the door. Attach the split head jamb on the side with access to the lock arm using 1 1/2" wood screws, and attach the other head jamb using 6d finish nails. Install the door latch hardware according to the manufacturer's instructions.
Install split jambs by fastening each to the front edge of split studs using 8d finish nails, maintaining a 3/16" clearance on both sides of the door. Attach the split head jamb on the side with access to the lock arm using 1 1/2" wood screws, and attach the other head jamb using 6d finish nails. Install the door latch hardware according to the manufacturer's instructions.
Install split jambs by fastening each to the front edge of split studs using 8d finish nails, maintaining a 3/16" clearance on both sides of the door. Attach the split head jamb on the side with access to the lock arm using 1 1/2" wood screws, and attach the other head jamb using 6d finish nails. Install the door latch hardware according to the manufacturer's instructions.
Fasten each split jamb to the front edge of the split stud,
using 8d finish nails. Maintain a 3/16" clearance on both sides
of door. G. INSTALL SPLIT JAMBS 1. Measure and cut the split jambs to size. With the door open all the way, hold the jambs against the split studs to confirm that the door is flush with jambs. If necessary, shim between the bumper and door until the door is flush. 2. Fasten each split jamb to front edge of split stud, using Sd finish nails. Maintain 3/16" clearance on both sides of door. H. INSTALL SPLIT HEAD JAMB 1. Measure and cut the split head jambs to size. 2. Use 1 1 /2" wood screws driven through countersunk pilot holes to attach the head jamb on the side that has access to the lock arm of the hangers. This allows for easy removal of the door. 3. Attach the other head jamb using 6d finish nails. Maintain 3/16" clearance on each side of the door. I. FINISHING TOUCHES 1. Install the included door guides on both sides of the door near the floor at the mouth of the pocket. 2. Install the latch hardware according to the manufacturer directions. 3. Finish the wallboard and install casing around the door. 4. Fill all nails holes with wood putty, then paint or stain the jambs and casing as desired. Attach the head jamb on the side that has access to the lock arm of the hangers with 1 W' wood screws dri ven through countersunk pilot holes. Install the door latch hardware according to the manufacturer instructions. A ccesso ries 125