You are on page 1of 3

Technological University of the Philippines-Taguig

Taguig, Metro Manila






THEVENINS NORTONS THEOREN
I. OBJECTIVE

To compare computed and measured values of a current applying
Thevenins Nortons Theorem.
II. INSTRUMENTS/COMPONENTS

1. Basic EE Trainer
2. VOM
3. Connection Leads
4. Decade Resistance Box

III. CIRCUIT DIAGRAM

IV. PROCEDURE

1. Consider R
L
=120 . Open the circuit and measure the voltage from where
R
L
was removed. Record voltage table 1.
2. Measure R
TH
with PS removed and replaced by short circuit. Measure R
TH
.
Name
Members
:
:
_________________________
_________________________
_________________________
_________________________
_________________________
_________________________
_________________________
_________________________
______
Date
Rating
:
:
______________________
______________________
______________________
Gontias, Marcelo
Dumadora, Cristel
Espiritu, Ralph Ivan
Fallejo,
Fue,
E,
Jerrera, Mark Lenin
Lala, Keith
Lino, Kristoffer
August 22, 2014
3. Draw Thevenins equivalent circuit and set required parameters and
measure I
L
. Record value.
4. Short circuit the point where R
L
is connected and measure I
SC
. Compared
data with Thevenins-Nortons conversion.
5. Calculate Thevenins paramaters and compare with measured values.


E
TH
R
TH
I
L
I
SC

MEASURED 8.25 V 68.0 0.045 A 0.13 A
CALCULATED 8.25 V 68.8 0.044 A 0.12 A
% DIFFERENCE 0 % 1.16 % 2.22 % 7.69 %
TABLE 1

V. QUESTIONS

1. Compare computed and calculated values, comment on the result.

()()




2. Give the observations and conclusions in this experiment.

Therefore, we have proved the Thevenins-Nortons Theoerm on this
experiment because we had gotten the same values of E
TH
and had less than
10% of percent difference which is good.

You might also like