Connect the Devices using the appropriate cable: a. Connect PC1 to Switch1 b. Connect Switch2 to the Fa0 / 0 interface on Router1 c. Assign the lowest (first) host address in the LAN1 subnet to PC1. Assign the second address in this subnet to the VLAN 1 interface on Switch1.
Connect the Devices using the appropriate cable: a. Connect PC1 to Switch1 b. Connect Switch2 to the Fa0 / 0 interface on Router1 c. Assign the lowest (first) host address in the LAN1 subnet to PC1. Assign the second address in this subnet to the VLAN 1 interface on Switch1.
Connect the Devices using the appropriate cable: a. Connect PC1 to Switch1 b. Connect Switch2 to the Fa0 / 0 interface on Router1 c. Assign the lowest (first) host address in the LAN1 subnet to PC1. Assign the second address in this subnet to the VLAN 1 interface on Switch1.
Direccin 172.16.1.1 172.16.1.33 172.16.1.2 172.16.1.34 172.16.1.30 172.16.1.35 Mscara 255.255.255.224255.255.255.240 255.255.255.224 255.255.255.240 255.255.255 .224 255.255.255.240 Gateway na na 172.16.1.1 172.16.1.33 172.16.1.1 172.16.1.33 Step 1: Connect the Devices. Connect the followingdevices using the appropriate cable: a. Connect PC1 to Switch1. b. Connect Switch1 to the Fa0/0 interface on R outer1. c. Connect Switch2 to the Fa0/1 interface on Router1. d. Connect PC1 to the Router1console port. Step 2: Determine the IP Addressing Scheme. Design an a ddressing scheme and fill in the Addressing Table based on the following require ments: a. Subnet the address space 172.16.1.0/24 toprovide 30 host addresses for LAN 1 while wasting the least amount of address space. b. Assign the first avai lable subnet to LAN 1. c. Assign the lowest (first) host address in this subnet to the Fa0/0interface on Router1. d. Assign the second address in this subnet to the VLAN 1 interface on Switch1. CCNA Exploration Network Fundamentals ENetwork Basic Configuration PT Practice SBA e. Assign thehighest (last) host IP address in this subnet to PC1. f. Using the next available subnet, further subnet it to provide 10 host addresses for LAN2 while wasting the least amount of address sp ace. g.Assign the lowest (first) host address in the LAN2 subnet to the Fa0/1 in terface on Router1. Step 3: Configure Router1. a. Configure Router1 with the fol lowing basic parameters: The router name isRouter1. Router(config)#hostname Rout er1 The privileged EXEC mode uses the following encrypted password: class Router 1(config)#enable password class Router1(config)#service password-encryption Enab leTelnet and console line login using the following password: cisco Router1(conf ig)#line vty 0 4 Router1(config-line)#password cisco Router1(config-line)#login Router1(config-line)#exit Configure the