properly cleaned and checking the content of the drum Drum might contain flammable or poisonous materials which might cause explosion or release of poisonous gas when cut. Make sure the bungs are taken off to be cleaned Steam clean the drum Avoid cutting drums that was used to contain poisonous or flammable materials Select and train operators in handling cutter Rotary cutter which is not handled by trained operators might cause malfunction of equipment which can lead to accidents from happening Operators undergo training Undergo trial run Under proper supervision Operator is equipped with protective gears When cutting the drum, shard might be flying in any direction at high speed endangering the operator. Besides that the blades might also break during operation which is very dangerous to the operator. Sparks might also be produced during operation Operator should be equipped with face shield Wear heavy duty gloves Wear proper clothing (apron) Operator should tie up long hair or remove anything dangling Handle cutter equipment at proper place When cutting, sparks are produced which might cause a fire if it lands on flammable materials Make sure that nobody get on the way when operation Make sure that place is brightly lighted Air in the area is being ventilated properly Make sure place is clean and free from flammable materials Make sure work piece is secure properly before operation of cutter If drum not properly secure, cutting the drum can be very difficult and dangerous. The work piece might slip and cause injury to the operator Provide a proper working are equipped with tools such as clamps which ensures the work piece to remain stationary while in operation. Cleaning up Rotary cutter are sharp and might injure people Place rotary cutter properly at a safe place. Keep it out of reach from children