2. In the select template manager, Left mouse click on the triangular button to the right of the Open Button, and select Open with no template-Imperial. 3. In the object properties toolbar pick Layer Properties Manager. 4. Click on the New Layer icon to create two layers by clicking on the 5. Layer Color Line type 6. Construction White Continuous Object Lines Blue Continuous 7. Set the construction layer as the current layer. Click on the button to close the layer properties Manager. 8. Right mouse click on the snap button in the status bar, and left mouse click on settings to open the drafting setting dialog box. 9. Switch the SNAP and GRID options on. 10. Turn on the Running object snap by clicking on the Object Snap On box. 11. Make a line of 2.250 at an angle of 45 degrees 12. Make another line of 0.5 at an angle of 90 degrees below the first line 13. Make a line of 1.375 at 37 degrees which meets the line of 0.5. 14. Make all these lines on the other edge of the first line (2.250) 15. Make a small line of 0.375 upward and make a parallel line of 2.250. 16. Similarly make another line parallel to above. 17. Now make a perpendicular line below the two parallel lines on both sides and join then with another line at an angle of 31 degrees. 18. Now on the below line and the distance of 0.75 from the edge make a line of 2.058 at an angle of 60 degrees and same as from the other edge. 19. Now make another line same as above but from the distance of 0.285 from the edge at an angle of 60 degrees. 20. Make a line of 3.0 at an angle of 31 degrees 21. Make another small line of 0.5 at 90 degrees below the above line 22. Between these lines make another line of 2.250 at 37 degrees and similarly on the other side. 23. Now join the line by joining the edges. 24. Make line joining the above line at 37 degrees at 2.250. 25. Now make 2 circles on the box of radius 0.50. 26. At last trim and use fillet, the radius of the fillet tool is 0.25 on all sides.