Professional Documents
Culture Documents
汽车空调制冷剂DIY加注补充方法
汽车空调制冷剂DIY加注补充方法
15%
DIY
1. DIY
2. R134A 250
3. DIY
4. L
5. AC DIY
30
45PSI 45PSI
()
65 18.33 25-35PSI
70 21.11 35-40PSI
75 23.89 35-40PSI
80 26.67 40-50PSI
85 29.44 45-55PSI
90 32.22 45-55PSI
95 35 50-55PSI
100 37.78 50-55PSI
105 40.56 50-55PSI
110 43.33 50-55PSI
7.
PSI
8.
9. L
1 AC
70 21.11
80 26.67
90 32.22
100 37.78
110 43.33
35-40PSI
40-50PSI
45-55PSI
50-55PSI
50-55PSI
3 L
1
2 100%
3
4
5
5 Start the Toyota's engine and warm it to its normal operating temperature.
6 Run the air-conditioner at its lowest setting. Give it a few minutes to get as cold as it
can.
7 Return to the Toyota's engine and your recharging kit. Turn the handle atop the Freon
container all the way down. This will crack the containers seal and let the Freon rush into
the Toyota's air-conditioner.
8 Monitor the pressure gauge on the canister. Turn the handle on top of the kit upwards
and shut off the flow of Freon once 60 seconds has elapsed.
9 Let 60 seconds of "not-charging" pass. This will let the recently added Freon circulate
through the Toyota's air-conditioning system.
10 Continue to monitor the pressure gauges while adding Freon in 60 second spurts. The
kit's gauge will tell you when the process is complete. If you need a second opinion, place
a thermometer into the system's central duct. The systems internal temperature will be
around 40 degrees during normal weather and between 40 and 60 during extremely hot
weather.
11 Remove the kit's coupler and hose from the low-side pressurized service port. Leave
the air-conditioner running, and give the Freon about 10 minutes to fully circulate. Then
turn the engine off.
R22
,
,,,
,,
, 0.4-0.5MPa
R134a
R12 2002 1 1
R134a
R134a R12