SERIES 60 SERVICE MANUAL 1-157 1.8. Installation of Crankshaft Oil Seal and Wear Sleeve Install the front oil seal as follows: An oil seal sleeve, integral to the seal assembly, is pressed onto the end of the crankshaft. The Federal Mogul(r)oil seal is installed using tool, J 35686-A. The Chicago Rawhide(r)(CR) oil seal is a registered trademark.
SERIES 60 SERVICE MANUAL 1-157 1.8. Installation of Crankshaft Oil Seal and Wear Sleeve Install the front oil seal as follows: An oil seal sleeve, integral to the seal assembly, is pressed onto the end of the crankshaft. The Federal Mogul(r)oil seal is installed using tool, J 35686-A. The Chicago Rawhide(r)(CR) oil seal is a registered trademark.
SERIES 60 SERVICE MANUAL 1-157 1.8. Installation of Crankshaft Oil Seal and Wear Sleeve Install the front oil seal as follows: An oil seal sleeve, integral to the seal assembly, is pressed onto the end of the crankshaft. The Federal Mogul(r)oil seal is installed using tool, J 35686-A. The Chicago Rawhide(r)(CR) oil seal is a registered trademark.
SERIES 60 SERVICE MANUAL 1-157 1.8. Installation of Crankshaft Oil Seal and Wear Sleeve Install the front oil seal as follows: An oil seal sleeve, integral to the seal assembly, is pressed onto the end of the crankshaft. The Federal Mogul(r)oil seal is installed using tool, J 35686-A. The Chicago Rawhide(r)(CR) oil seal is a registered trademark.
6SE483 9610 1996 DETROIT DIESEL CORPORATION From Bulletin 6-60-98 1-157 1.8.7 Installation of Crankshaft Oil Seal and Wear Sleeve Install the front oil seal as follows: An oil seal sleeve, integral to the seal assembly, is pressed onto the end of the crankshaft and provides a replacement wear surface at the point of contact with the oil seal. The sleeve and seal are supplied assembled. The assembly is installed using the crankshaft oil seal and sleeve installation tool. The Federal Moguloil seal is installed using tool, J 35686-A, with collar J 3568610. The Chicago Rawhide(CR) oil seal is installed using J 35686B, but uses collar J 3568620. See Figure 1-128 and see Figure 1-129. Federal Mogulis a registered trademark. Chicago Rawhideis a registered trademark. Figure 1-128 Crankshaft Oil Seal and Sleeve Installation Tool Set 1.8 CRANKSHAFT OIL SEALS All information subject to change without notice. 1-157a From Bulletin 6-60-98 6SE483 9610 1996 DETROIT DIESEL CORPORATION 1. Thrust Plate 6. Crankshaft 2. Wrench Flat 1/2 in., Guide Stud 7. Guide Stud Retainer (O-ring) 3. 3/4 - 10 Hex Nut 4. Seal and Wear Sleeve Assembly 5. Gear Case/Flywheel Housing Figure 1-129 Front Crankshaft Oil Seal Installer