6SE483 9610 1996 DETROIT DIESEL CORPORATION From Bulletin 2-60-98 Rev. 12-16a 5. Place the feeler gage from step 4 between the leveling screw and the rocker arm adjusting screw. Turn the leveling screw clockwise until a light drag is felt on the feeler gage. See Figure 12-9. Figure 12-9 Adjusting Leveling Screw 6. Hold the leveling screw in this position and tighten the locknut to 47 Nm (35 lbft). 7. Repeat the adjustment procedures in steps 1 through 6 for the remaining cylinders. Rotate the engine when necessary to put the exhaust valves in the closed position for slave piston adjustment. 12.2 VALVE LASH, INJECTOR HEIGHT (TIMING) AND JAKE BRAKE LASH ADJUSTMENT All information subject to change without notice. 12-16b From Bulletin 2-60-98 Rev. 6SE483 9610 1996 DETROIT DIESEL CORPORATION This Page Intentionally Left Blank.
Gas-Engines and Producer-Gas Plants
A Practice Treatise Setting Forth the Principles of Gas-Engines and Producer Design, the Selection and Installation of an Engine, Conditions of Perfect Operation, Producer-Gas Engines and Their Possibilities, the Care of Gas-Engines and Producer-Gas Plants, with a Chapter on Volatile Hydrocarbon and Oil Engines