Professional Documents
Culture Documents
Taladro Milwakee 0300-20
Taladro Milwakee 0300-20
BULLETIN NO.
54-06-2925
CATALOG NO.
REVISED BULLETIN
DATE
Jan. 2006
070A
WIRING INSTRUCTION
58-01-1805
00
0
EXAMPLE:
Component Parts
(Small #) Are Included
When Ordering The
Assembly (Large #).
FIG.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
34
35
36
37
PART NO.
02-04-0640
02-04-0645
02-04-0852
02-04-1229
02-50-1611
02-50-2400
22-84-0845
06-54-0325
06-75-2850
06-75-3150
06-82-7275
12-99-2565
16-10-2210
18-07-2206
22-18-1210
44-76-0210
22-64-1130
23-66-2585
28-14-2390
28-28-2320
31-15-2010
31-50-2050
32-40-0100
32-75-0100
34-80-2300
36-66-0100
38-50-5735
42-14-0450
42-68-0800
43-44-0985
43-62-0845
44-60-1700
45-36-1095
45-88-7990
45-30-0030
48-66-1355
DESCRIPTION OF PART
NO. REQ.
Ball Bearing
(1)
Ball Bearing
(1)
Ball Bearing
(1)
Ball Bearing
(1)
Needle Bearing
(1)
Needle Bearing
(1)
Fan
(1)
3/8-16 Square Nut
(1)
3/8-16 x 5-1/2 Hex Cap Screw
(1)
1/4-20 x 1 L.H. Thread Slt. Screw
(1)
7-18 x 3/4 Slotted Plastite T-20
(6)
Service Nameplate
(1)
Armature
(1)
Field
(1)
Brush Card Assembly
(1)
Cord Protector
(1)
Cord Set
(1)
Switch
(1)
Gearcase
(1)
Diaphragm
(1)
Handle Halve
(1)
Motor Housing
(1)
Intermediate Gear
(1)
Spindle Gear
(1)
Retaining Ring
(1)
Intermediate Shaft
(1)
Spindle
(1)
Baffle Assembly
(1)
Side Handle Clamp
(1)
Gasket
(1)
Side Handle
(1)
Ground Pin
(1)
Spindle Spacer
(1)
Thrust Washer
(1)
Slug
(2)
1/2 Chuck
(1)
FIG.
38
39
40
41
42
43
PART NO.
48-66-3280
48-66-4040
45-30-0035
23-52-1610
22-18-1310
49-15-0265
DESCRIPTION OF PART
Chuck Key
Chuck Key Holder
Slug
Brush Spring
Brush Assembly
Side Handle Assembly
NO. REQ.
(1)
(1)
(1)
(2)
(2)
(1)
NOTES:
Support the output ball bearing inside the gearcase before
pressing off the spindle gear.
Needle bearings to be pressed flush to .010 under flush
from the end which has the vendors identification.