Professional Documents
Culture Documents
C-MAX Manual
C-MAX Manual
Owner's handbook
The information contained in this publication was correct at the time of going to print. In the
interest of development the right is reserved to change specifications, design or equipment
at any time without notice and without incurring any obligations. This publication, or part
thereof, may not be reproduced nor translated without our approval. Errors and omissions
excepted.
Ford Motor Company 2007
All rights reserved.
Part number: 8M5J-19A321-BDA (CG3478en) 10/2007 20071114175745
Table of contents
Introduction
Engine immobiliser
Principle of operation.....................52
Coded keys.....................................52
Arming the engine immobiliser.....52
Disarming the engine
immobiliser...................................52
Quick start
Quick start.........................................10
Child safety
Alarm
Child seats........................................20
Child seat positioning......................21
Booster cushions............................23
ISOFIX anchor points......................24
Child safety locks............................26
Steering wheel
Adjusting the steering wheel.........55
Horn..................................................55
Audio control...................................55
Voice control....................................57
Occupant protection
Principle of operation......................27
Fastening the seat belts.................31
Seat belt height adjustment..........33
Using seat belts during
pregnancy....................................33
Disabling the passenger
airbag............................................33
Pedals
Adjusting the pedals.......................58
Locks
Lighting
Lighting control................................64
Table of contents
Autolamps........................................65
Front fog lamps...............................65
Rear fog lamps................................65
Headlamp levelling..........................66
Adaptive front lighting system
(AFS)..............................................68
Hazard warning flashers................70
Direction indicators..........................71
Interior lamps...................................72
Changing a bulb..............................74
Electric sunroof...............................116
Seats
Sitting in the correct position.......120
Manual seats..................................120
Head restraints...............................121
Electric seats..................................122
Rear seats......................................124
Heated seats.................................132
Convenience features
Sun visors.......................................133
Sun blinds.......................................133
Instrument lighting dimmer..........134
Cigar lighter....................................134
Auxiliary power sockets...............134
Centre console..............................135
Cool box..........................................137
Storage compartments................137
Seat back trays..............................138
Glasses holder...............................139
Toll reader.......................................139
Childminder mirror.........................140
Auxiliary input (AUX IN) socket.....140
Electric windows.............................84
Exterior mirrors................................85
Electric exterior mirrors..................86
Interior mirror...................................87
Instruments
Gauges.............................................88
Warning lamps and indicators......90
Audible warnings and
indicators......................................94
Information displays
General information........................96
Personalised settings.....................99
Information messages.................103
Climate control
Principle of operation....................107
Air vents..........................................107
Manual climate control.................108
Automatic climate control.............111
Heated windows and mirrors......114
Auxiliary heater...............................114
Table of contents
Fuel and refuelling
Load carrying
Safety precautions........................149
Fuel quality - Petrol........................149
Fuel quality - Flexible Fuel............149
Fuel quality - Diesel.......................150
Catalytic converter........................150
Fuel filler flap....................................151
Refuelling.........................................151
Fuel consumption..........................151
Technical specifications................152
General information.......................167
Luggage covers.............................167
Rear under floor storage..............168
Towing
Towing a trailer...............................169
Detachable tow ball......................169
Driving hints
Running-in.......................................173
Transmission
Manual transmission.....................154
Automatic transmission................154
Emergency
equipment
Brakes
Principle of operation....................158
Hints on driving with ABS.............158
Parking brake.................................159
Status after a
collision
Stability control
Principle of operation....................160
Using stability control.....................161
Fuses
Fuse box locations........................176
Changing a fuse.............................177
Fuse labels......................................177
Fuse specification chart................179
Parking aid
Principle of operation....................162
Using the parking aid....................162
Cruise control
Vehicle recovery
Principle of operation....................164
Using cruise control......................164
Towing points.................................185
Towing the vehicle on four
wheels.........................................186
Table of contents
Maintenance
Vehicle care
General information......................188
Opening and closing the
bonnet.........................................189
Engine compartment overview 1.6L Duratec-16V (Sigma)/1.6L
Duratec-16V Ti-VCT (Sigma).....190
Engine compartment overview 1.8L Duratec-HE (MI4)/2.0L
Duratec-HE (MI4).......................192
Engine compartment overview 1.6L Duratorq-TDCi (DV)
Diesel...........................................194
Engine compartment overview 1.8L Duratorq-TDCi (Lynx)
Diesel...........................................196
Engine compartment overview 2.0L Duratorq-TDCi (Puma)
Diesel...........................................198
Engine oil dipstick - 1.6L
Duratec-16V (Sigma)/1.6L
Duratec-16V Ti-VCT (Sigma).....199
Engine oil dipstick - 1.8L
Duratec-HE (MI4)/2.0L
Duratec-HE (MI4).......................199
Engine oil dipstick - 1.6L
Duratorq-TDCi (DV) Diesel......200
Engine oil dipstick - 1.8L
Duratorq-TDCi (Lynx) Diesel....200
Engine oil dipstick - 2.0L
Duratorq-TDCi (DW) Diesel.....200
Engine oil check............................200
Engine coolant check...................201
Brake and clutch fluid check......202
Power steering fluid check.........202
Washer fluid check.......................203
Technical specifications...............204
Vehicle battery
Battery care...................................209
Using booster cables...................209
Changing the vehicle battery......210
Vehicle identification
Vehicle identification plate...........226
Vehicle identification number
(VIN).............................................226
Engine number - 1.6L Duratec-16V
(Sigma)/1.6L Duratec-16V Ti-VCT
(Sigma).......................................226
Engine number - 1.8L Duratec-HE
(MI4)/2.0L Duratec-HE
(MI4)............................................226
Engine number - 1.6L
Duratorq-TDCi (DV) Diesel/2.0L
Duratorq-TDCi (Puma)
Diesel...........................................227
Engine number - 1.8L
Duratorq-TDCi (Lynx) Diesel.....227
Table of contents
Technical specifications
Technical specifications...............228
Telephone
General information......................231
Telephone setup...........................231
Bluetooth setup............................233
Telephone controls......................234
Using the telephone - Vehicles
Without: Navigation System.....235
Using the telephone - Travel Pilot
EX................................................238
Voice control
Principle of operation....................241
Using voice control.......................242
Audio unit commands.................242
Telephone commands................247
Navigation system
commands.................................252
Climate control commands........252
Appendices
Type approvals..............................255
Type approvals..............................255
Electromagnetic compatibility.....262
Introduction
Symbols on your vehicle
PARTS AND
ACCESSORIES
SYMBOLS GLOSSARY
WARNING
CAUTION
You risk damaging your vehicle
if you do not follow the
instructions highlighted by the caution
symbol.
Introduction
Bumper and radiator grille
Radiator grille
Front and rear bumper
Bonnet
Wings
Doors
Luggage compartment lid or
tailgate
E89933
Exterior mirror
E89934
Glass
E89932
Rear window
Side glass
Windscreen
Introduction
E89936
E89935
Lighting
Rear lamps
Headlamp
Quick start
QUICK START
Instrument panel overview
Left-hand drive
E78209
Lighting control. See Lighting control (page 64). Front fog lamps.
See Front fog lamps (page 65). Rear fog lamp. See Rear fog
lamps (page 65).
10
Quick start
C
Card holder.
11
Quick start
Right-hand drive
E78210
Card holder.
12
Quick start
D
Lighting control. See Lighting control (page 64). Front fog lamps.
See Front fog lamps (page 65). Rear fog lamp. See Rear fog
lamps (page 65).
13
Quick start
Locking and unlocking
Unlocking the vehicle
C
E71963
Unlock
Lock
Tailgate unlock
E78262
14
Quick start
Keyless entry
E78282
Keyless starting
E85766
WARNING
15
Quick start
Manual climate control
Windscreen
defrosting/demisting
1
E95178
E71382
E77935
3
E95179
WARNING
Make sure that you fully engage
the locking lever when returning
it to its original position.
See Adjusting the steering
wheel (page 55).
16
Quick start
Automatic climate control
Direction indicators
E78730
Windscreen
defrosting/demisting
Recirculated air
E71098
Air conditioning ON
Autolamps
Autowipers
E71014
E72162
17
Quick start
The rain sensor will continuously
measure the amount of water on the
front screen and adjust the speed of
the front wipers automatically.
Adjust the sensitivity of the rain
sensor using the rotary control.
See Windscreen wipers (page
59).
Rear seats
E78064
Airbag
E78062
E69213
WARNING
To avoid the risk of death or
serious injury, never use a
rearward facing child restraint in the
front, unless the air bag is off.
See Child safety (page 20).
18
Quick start
See Disabling the passenger
airbag (page 33).
Manual transmission
Reverse gear 6-speed
transmission
2
1
E75052
Automatic transmission
Note: When the engine is started,
the brake pedal and the
selector lever button must be
depressed before the selector lever
can be moved from the park position
P.
See Transmission (page 154).
19
Child safety
CHILD SEATS
WARNINGS
If your vehicle has been involved
in an accident, have the child
restraints checked by properly
trained technicians.
Note: Mandatory use of child
restraints varies from country to
country.
A choice of ECE approved child
restraints which have been
specifically tested and approved for
your vehicle are available from your
Dealer.
E68916
WARNINGS
Secure children that are less
than 150 centimetres tall or less
than 12 years of age in a suitable,
approved child restraint, in the rear
seat.
E68918
20
Child safety
Child safety seat
E68920
0+
II
III
Up to 10
kg
Up to 13
kg
9-18 kg
15-25 kg
22-36
kg
Baby
safety
seat
Baby
safety
seat
Child
safety
seat
Booster
seat or
cushion
Booster
seat or
cushion
Front passenger
airbag ON
Front passenger
airbag OFF
Rear seats
U Suitable for universal category child restraints approved for use in this mass
group.
X Not suitable for children in this mass group.
21
Child safety
1
U Suitable for universal category child restraints approved for use in this mass
group. However, we recommend that you secure children in a government
approved child restraint, in the rear seat.
22
Child safety
We recommend that you use a
booster seat that combines a
cushion with a backrest instead of a
booster cushion only. The raised
seating position will allow you to
position the shoulder strap of the
adult seat belt over the centre of your
childs shoulder and the lap strap
tightly across its hips.
BOOSTER CUSHIONS
WARNINGS
Do not install a booster seat or
a booster cushion with only the
lap strap of the seat belt.
Do not install a booster seat or
a booster cushion with a seat
belt that is slack or twisted.
Booster cushion
E68924
Booster seat
E70710
23
Child safety
Attaching child safety seats
with top tethers
E75531
E78299
WARNINGS
Attach the tether strap only to
the appropriate tether anchor
as shown. The tether strap may not
work properly if attached somewhere
other than the correct tether anchor.
24
Child safety
A third anchor point has been
provided for child seats that are
equipped with a top tether, available
for use in the forward facing
configuration.
The top tether anchors in your vehicle
are located on the floor of the
luggage compartment.
The tether strap should be routed
beneath the raised rear head
restraint, to the anchor point on the
floor of the luggage compartment.
The anchor point is identified by a
pictogram.
After installing the child safety seat,
tighten the tether strap according to
the manufacturers instructions.
25
Child safety
CHILD SAFETY LOCKS
E78298
WARNING
When the child safety lock is
activated, the door can only be
opened from outside.
Turn the key in the rear door in the
direction of the arrow to activate the
lock. To deactivate the lock turn the
key in opposite direction to the arrow.
26
Occupant protection
PRINCIPLE OF OPERATION
Airbags
E78293
WARNING
27
Occupant protection
WARNINGS
Repairs to either of the front
seat covers, the sensors
attached to the seats as well as to
the roof lining should only be carried
out by properly trained technicians.
Injuries may result if the side airbags
are triggered inadvertently.
WARNING
Always wear the seat belt and
keep sufficient distance
between the driver and the steering
wheel. Only when the seat belt is
used properly, can it hold the body
in a position which allows the airbag
to achieve its optimum effect. There
is a risk of injury when the airbag
deploys.
E66553
E72325
28
Occupant protection
The front airbags activate during
significant collisions which are
either frontal or up to 30
degrees from the left or the right.
The airbags inflate within a few
thousandths of a second. They will
deflate on contact with the front
occupants thus cushioning forward
body movement.
WARNINGS
Repairs to the steering wheel,
steering column and airbag
system should be carried out by
properly trained technicians.
Always keep the areas in front
of the airbags free. Never affix
anything to or over these areas.
These areas should only be wiped
with a damp cloth, never with a wet
cloth.
Side air bags
E72326
E72328
E78294
29
Occupant protection
The side airbags are not activated
upon minor lateral collisions nor upon
front or rear impacts.
WARNINGS
The seat belts should fit tightly
around the body.
E72329
E72333
WARNING
The belt pretensioners must not
be removed. If the
pretensioners are deployed during
an accident, they must be replaced.
Have the pretensioners serviced and
disposed of by specially trained
personnel only.
Seat belts
WARNINGS
Use seat belts at all times.
Never use a seat belt for more
than one person.
Avoid wearing thick clothing.
30
Occupant protection
The belt pretensioner is not triggered
in any side, rear or minor frontal
collisions.
E74124
WARNING
Insert the tongue into the buckle
until a distinct click is heard,
otherwise the seat belt will not be
locked correctly.
Pull the belt out steadily. It may lock
if pulled sharply or if the vehicle is on
a slope.
E74127
WARNING
In order to ensure that the
centre belt works properly, the
rear seatback must be correctly
engaged.
Make sure that each seat belt uses
the correct buckle.
31
Occupant protection
E74125
E74126
E78080
32
Occupant protection
Fold the smaller seat belt tongue
back and insert the larger belt tongue
into the retaining slot as shown.
WARNING
Position the seat belt correctly
for your safety and that of your
unborn child. Do not use only the lap
strap or the shoulder strap.
DISABLING THE
PASSENGER AIRBAG
WARNING
E78081
E71313
E68587
33
Occupant protection
Fitting the passenger
airbag deactivation switch
WARNING
WARNING
E71312
Disabled
Enabled
34
E78253
PROGRAMMING THE
REMOTE CONTROL
A maximum of eight remote controls
can be programmed (including the
ones delivered with the vehicle). The
remote controls must remain inside
the vehicle during the programming
procedure. Fasten the front seat
belts and close all doors to ensure
that conflicting chimes do not sound
during programming.
E78254
35
Reprogramming the
unlocking function
Passive key
Remove the spare key.
E78255
36
E78256
E78258
E78257
37
Remote control
Passive key
E74386
E78259
38
Type 1
Type 2
Passive key
39
Locks
On vehicles without remote control,
they can also be locked and
unlocked at the front passengers
door.
LOCKING AND
UNLOCKING
Doors
E78260
Right-hand drive
E72194
E78261
40
Locks
Tailgate
E78263
E78262
E78264
41
Locks
Right-hand drive
E72198
E78265
WARNING
Double locking should not be
activated when persons are
inside the vehicle.
42
Locks
Unlocking the tailgate
E78268
E78267
WARNING
If a failure occurs in the vehicles
electrical system the drivers
door can still be individually unlocked
with the key.
E78269
No door is opened.
The luggage compartment is not
opened.
The ignition is not switched on.
43
Locks
E78270
E78270
KEYLESS ENTRY
Left-hand drive
General information
The key free system allows the driver
to operate the vehicle without the
use of a key or remote control.
The advantages of the key free
system are:
the vehicle can be locked and
unlocked without having to insert
a key into the door lock or press
any buttons on a remote control.
the engine can be started without
the need to insert a key into the
ignition. See Starting the
engine (page 141).
E78271
Right-hand drive
E78272
44
Locks
WARNING
Do not store the passive key
with metal objects or electronic
devices such as mobile phones as
this could cause interference with the
key free system.
The vehicle is operated by means of
a passive key See Type approvals
(page 255). . The passive key can also
be used as a remote control. See
Locking and unlocking (page
40).
E78276
Spare key
A spare key is provided for the
following situations:
If the passive key frequencies are
jammed.
If the passive key battery is flat.
If the key free function has been
deactivated using the information
display.
When the vehicle is being towed.
To reactivate a deactivated
passive key.
Passive key
E78277
45
Locks
Insert the spare key blade into the
container until it clicks. Make sure the
blade is inserted the right way up.
2
1
E78287
E78284
E78285
E78286
46
Locks
E78288
E78278
E78279
47
Locks
If the front passengers door or one
of the rear doors is the first door
which is opened, all the doors and
the tailgate will be unlocked.
Tailgate
E78280
E78281
E78283
48
Locks
Locking the vehicle
E78282
WARNING
The vehicle does not lock itself
automatically. If no locking
button is pressed, the vehicle will
remain unlocked.
Note: Before leaving the vehicle,
ensure that the ignition switch is
pulled out. See Ignition switch
(page 141).
49
Locks
Global closing
WARNING
Take care when using global
closing. In an emergency, press
a button immediately to stop.
Global opening
E71956
E71955
E78275
50
Locks
WARNING
Take care when using global
closing. In an emergency, press
the button on the drivers door
handle to stop.
Note: Global closing can be
activated using the button on the
drivers door handle. Global opening
and closing can also be activated
using the buttons on the passive key.
To close all the windows, press and
hold the button on the drivers door
handle for at least two seconds. The
anti-trap function is also active during
global closing.
51
Engine immobiliser
PRINCIPLE OF
OPERATION
CODED KEYS
Note: Do not shield your keys with
metal objects. This may prevent the
receiver from recognising your key
as a valid one.
Note: Have all of your remaining
keys erased and recoded if you lose
a key. Ask your dealer for further
information. Have replacement keys
recoded together with your existing
keys.
52
Alarm
ARMING THE ALARM
WARNING
This system functions correctly
only if all windows and the
sunroof are completely closed. In
addition to this, the sensors located
in the interior lamp unit must not be
covered up. The system should not
be activated if any persons, animals
or other moving objects are inside
the vehicle.
Interior sensors
E71401
53
Alarm
Britain and Ireland only
E80555
E80556
54
Steering wheel
ADJUSTING THE
STEERING WHEEL
WARNING
Make sure that you fully engage
the locking lever when returning
it to its original position.
WARNING
Never adjust the steering wheel
when the vehicle is moving.
HORN
2
2
E78023
1
E95178
AUDIO CONTROL
Select radio, CD or cassette mode
on the audio unit.
The following functions can be
operated with the remote control:
3
E95179
55
Steering wheel
Volume
Mode
E78046
E78048
Seek
E78047
56
Steering wheel
VOICE CONTROL
E78049
57
Pedals
ADJUSTING THE PEDALS
E78045
WARNINGS
Never adjust the pedals when
the vehicle is moving.
When a floor mat is fitted, the
pedals may get caught on the
mat. When using floor mats, always
ensure that there is enough
clearance for the pedals to move.
Press the upper part of the switch to
move the pedals towards the driver.
Press the lower part of the switch to
move the pedals away from the
driver.
See Sitting in the correct
position (page 120).
58
WINDSCREEN WIPERS
C
B
E71013
Intermittent wipe
E71012
Single wipe
Intermittent wipe or
autowipers
Normal wipe
Autowipers
E71014
59
WARNINGS
Replace the wiper blades as
soon as they begin to leave
bands of water and smears or when
they do not completely remove water
from the windscreen. If the blades
are not replaced, the rain sensor will
continue to detect water on the
windscreen. This will result in the
wipers continuing to operate
although the majority of the
windscreen is dry.
B
E71015
Low sensitivity
High sensitivity
60
WINDSCREEN WASHERS
E71017
E71016
WARNING
Do not operate the washer for
more than 10 seconds at a time,
and never when the reservoir is
empty.
61
ADJUSTING THE
WINDSCREEN WASHER
JETS
E71018
WARNING
E73425
HEADLAMP WASHERS
While the lever is pulled towards the
steering wheel the washer will work
in conjunction with the wipers.
Once the wash/wipe cycle is
completed, the wipers will pause and
then perform one more wipe to clear
the windscreen.
After releasing the lever, the wipers
operate for a short time.
E73427
62
WARNING
Do not operate the washer for
more than 10 seconds at a time,
and never when the reservoir is
empty.
E78156
E66644
63
Lighting
Main and dipped beam
LIGHTING CONTROL
Lighting control positions
E71095
Headlamp flasher
E71094
Off
Headlamps
Parking lamps
Parking lamps
CAUTION
Prolonged use of the parking
lamps will discharge the battery.
64
Lighting
AUTOLAMPS
WARNING
Only use the front fog lamps
when visibility is considerably
restricted by fog, snow or rain.
E73840
E71097
WARNING
E71096
65
Lighting
HEADLAMP LEVELLING
E78044
E65990
Front seats
Rear seats
compartment
1-2
1-2
1-2
max.
66
Lighting
Load
Persons
Front seats
Rear seats
compartment
max.
max.
67
Lighting
ADAPTIVE FRONT LIGHTING SYSTEM (AFS)
E72897
without AFS
with AFS
The system will not operate when
you have switched on the daytime
running lamps or when you have
selected reverse gear.
68
Lighting
A message will appear in the
information display and the headlamp
indicator flashes if the system
malfunctions. See Information
messages (page 103). The
headlamps will move to a fixed
central or dipped position. Have the
system checked as soon as possible.
69
Lighting
HAZARD WARNING
FLASHERS
Note: Depending on applicable laws
and regulations in the country for
which your vehicle was originally built,
the hazard warning flashers may flash
if you brake heavily.
E71943
70
Lighting
DIRECTION INDICATORS
E71098
71
Lighting
If you set the switch to position C
with the ignition switch off, the
courtesy lamp will come on. It will go
off automatically after a short time to
prevent the vehicle battery from
discharging. To switch it back on,
switch on the ignition for a short time.
INTERIOR LAMPS
Courtesy lamp
A B C
Reading lamps
E71945
Off
Door contact
On
E71946
E72900
72
Off
On
Lighting
If you switch off the ignition, the vanity
mirror lamps will go off automatically
after a short time to prevent the
vehicle battery from discharging. To
switch them back on, switch on the
ignition for a short time.
73
Lighting
CHANGING A BULB
WARNINGS
On vehicles fitted with Xenon
headlamps, have the headlamp
bulbs changed by an expert. There
is a risk of injury due to high voltage.
During operation, the bulbs and
their surroundings get hot.
Switch off the lights and let the bulbs
cool down before replacing them.
Always switch off lights and ignition
before replacing any bulb.
Never touch the glass of the bulbs.
Fit only bulbs having a UV filter.
Always replace a faulty bulb with a
new one of the same type. After
replacing a bulb, check that the lights
operate correctly.
E78106
E78107
WARNING
74
Lighting
Opening the headlamp
assembly (Type 1)
E78109
E78108
E91732
75
Lighting
Headlamps main beam
H1, 55 watt halogen bulb
E78110
E78111
Side lamps
5 watt wedge base bulb
E91734
76
Lighting
1. Carefully remove the side
repeater.
2. Hold the bulb holder, turn the
housing anti-clockwise and
remove it.
3. Remove the bulb.
E78112
E78114
WARNING
The retainer tabs on the edge
of the scull cap are very
delicate. When removing and
reinstalling the scull cap, take care
not to break them off.
Side repeaters
5 watt spherical bulb
E78115
E78869
77
Lighting
E78118
E78116
E78119
Approach lamps
5 watt wedge base bulb
78
Lighting
Front fog lamps (Type 2)
H8, 35 watt halogen bulb
E91735
E78120
E78121
79
Lighting
Install in the reverse order.
Rear lamps
Open the tailgate.
Remove the pillar panel trim inside
the luggage compartment.
E78124
E78122
E78125
E78123
80
Lighting
E78126
E72556
E78128
5 watt festoon
81
Lighting
Interior lamps
Reading lamps
3
E78131
E78129
Luggage compartment
lamp
5 watt spherical bulb
E78130
E78132
82
Lighting
Carefully prise out the lamp assembly
from the holder with a flat-bladed
screwdriver and remove the bulb.
Install in the reverse order.
Footwell lamp
5 watt wedge base bulb
Pull the bulb out and replace it.
83
ELECTRIC WINDOWS
WARNING
E70850
Anti-trap function
WARNING
Careless closing of the windows
can override the protection
function and cause injuries.
E70848
84
CAUTION
While you close the window for
the third time, the anti-trap
function is disabled. Make sure there
are no obstacles in the way of the
closing window.
To override this protection function
when there is a resistance, e.g. in the
winter, proceed as follows:
1. Close the window twice until it
reaches the resistance and let it
reverse.
2. Close the window a third time to
the resistance. The anti-trap
function is disabled and you
cannot close the window
automatically. The window will
override the resistance and you
can close it fully.
3. If the window does not close after
the third attempt, have it checked
by an expert.
EXTERIOR MIRRORS
Convex mirrors
85
WARNING
Do not overestimate the
distance of the objects that you
see in the convex mirror. Objects
seen in convex mirrors will appear
smaller and further away than they
actually are.
Folding mirrors
A
B
E70846
E71043
Left-hand mirror
Off
Right-hand mirror
E70847
86
E78811
INTERIOR MIRROR
E71272
87
Instruments
GAUGES
Type 1
E
E98733
Tachometer
Fuel gauge
Speedometer
Information display
88
Instruments
Type 2 and 3
E
E98738
Tachometer
Fuel gauge
Speedometer
Information display
89
Instruments
Engine coolant temperature
gauge
All vehicles
Shows the temperature of the engine
coolant. At normal operating
temperature, the needle will remain
in the centre section.
Doors open
Brake system
Engine systems fault
Frost
Power steering
Ignition
CAUTION
Do not restart the engine until the
cause of overheating has been
resolved.
Fuel gauge
Airbag warning lamp
Airbag
Oil pressure
Engine immobiliser
ABS
Stability control (ESP)
Engine
90
Instruments
Doors open warning lamp
WARNING
Illuminates to indicate a
malfunction of the engine
and powertrain related
systems. Stop the vehicle as soon as
safely possible and switch off the
engine immediately. Have the engine
checked by an expert immediately.
E71340
is in use.
Direction indicator
91
Instruments
Frost warning lamp
WARNING
Even if the temperature rises to
above +4C there is no
guarantee that the road is free of
hazards caused by inclement
weather.
At temperatures between
+4C and +1C, the orange
frost warning lamp
illuminates. At temperatures below
+1C, the warning lamp glows red.
Headlamp indicator
Message indicator
92
Instruments
Oil pressure warning lamp
WARNINGS
Never sit on top of a buckled
seat belt to avoid the seat belt
reminder. The restraint system can
only work properly if passengers
have buckled up their seat belts.
WARNING
Do not resume the journey if the
oil level is correct. Have the
engine checked by an expert.
If it stays on after starting or
illuminates during a journey,
stop immediately, switch off
the engine and check the engine oil
level. Top up straight away if the level
is low.
Illuminates to indicate a
malfunction of the power
steering system. Full
steering will be maintained but you
will need to exert greater force on
the steering wheel. Have the system
checked by an expert as soon as
possible.
93
Instruments
Key outside car
AUDIBLE WARNINGS
AND INDICATORS
Automatic transmission
If position P is not selected, a warning
chime will sound when the drivers
door is opened.
Key-in-ignition
Except vehicles with the key
free system
Frost
WARNING
Even if the temperature rises to
above +4C there is no
guarantee that the road is free of
hazards caused by inclement
weather.
Lights on
A warning chime will sound if the
drivers door is opened with the
exterior lights switched on and the
ignition switched off.
Low fuel
A warning chime will sound at the
following ranges: 80 km (50 miles),
40 km (25 miles), 20 km (12 miles), 0
km (0 miles).
94
Instruments
Seat belt reminder
WARNINGS
The seat belt reminder remains
in stand-by mode after the
driver has fastened his/her seat belt.
It will be reactivated if the driver
unbuckles his/her seat belt.
Never sit on top of a buckled
seat belt to avoid the seat belt
reminder function. The restraint
system can only work properly if
passengers have buckled up their
seat belts.
When the vehicles speed exceeds
23 km/h (14 mph), a chime will sound
if the drivers seat belt is unbuckled.
The chime will stop after eight
minutes.
95
Information displays
Turn the rotary control to scroll
through the available displays within
a menu or to choose a setting. To
scroll automatically, hold the rotary
control in the upward or downward
position.
GENERAL INFORMATION
WARNING
Do not operate the information
display controls when the
vehicle is moving.
Various systems can be
programmed using the information
display and the multi-function lever
on the steering column.
Controls
E73266
Type 2 and 3
E73265
96
Information displays
Menu structure
Reset Trip
Trip Odo
Avg Fuel
Avg Speed
All
Messages
Car Setup
Steering
Auto Trans.
Standard
Sport
Comfort
Economy
Standard
Adaptive
Sport
ESP
Clock
Set Clock
24 Hour Mode
12 Hour Mode
Setup
Display
Configure
Help Screen
Radio Info
Phone Info
NAV Info
E98875
97
Always off
On Guidance
Always on
Information displays
B
C
Language
Measure Unit
English
German
Italian
French
Spanish
Turkish
Russian
Dutch
Polish
Swedish
Portuguese
Metric
Imperial
Chimes
Low Fuel
General Warn
General Info
Door Ajar
Key Free act.
E98876
Aux Heater
98
Information displays
PERSONALISED
SETTINGS
A
Park Heater
Time 1 on
Set Time 1
Monday
Tuesday
Wednesday
Thursday
Friday
Saturday
Sunday
Time 2 on
Set Time 1
Monday
Tuesday
Wednesday
Thursday
Friday
Saturday
Sunday
Set once
Active now
E98884
99
Information displays
ATM personalisation
Note: Kickdown functions in the
same way in all three modes.
Units of measure
To toggle between metric and
imperial units, scroll to this display and
press the SET/RESET button.
ESP
Select this option to activate ESP.
Language setting
A choice of eleven languages are
available.
Scroll to this display using the rotary
control and press the SET/RESET
button to select the desired
language. Turn the rotary control to
save the setting and exit the menu.
Clock setting
Auxiliary heater
programming
See Auxiliary heater (page 114).
100
Information displays
To programme the auxiliary heater,
scroll to this display using the rotary
control and press the SET/RESET
button.
Instant control
Programme times
Note: The programmed time is the
time at which you wish the vehicle to
be warm and ready to drive, not the
time at which the heater switches on.
101
Information displays
Set the hours with the rotary control.
Chime deactivation
The following chimes can be
deactivated:
Low fuel warning.
General warning messages.
102
Information displays
Door ajar.
INFORMATION MESSAGES
Doors open
Message
Warning
lamp
System
red
Locks.
red
Locks.
red
Locks.
red
Locks.
red
Locks.
Bonnet open
red
Locks.
amber
Warning
lamp
System
Keyless system
Message
red
red
amber
Locks.
amber
103
Information displays
Message
Warning
lamp
System
Lighting
Message
Warning
lamp
System
red
amber
Warning
lamp
System
Maintenance
Message
red
Cooling system.
red
Brakes.
red
Engine malfunction
104
Information displays
Warning
lamp
System
Acceleration reduced
red
amber
Message
Service oil
Screen washer.
Service Indication
Power steering
Message
Warning
lamp
System
amber
Warning
lamp
System
red
Transmission
Message
105
Information displays
Message
Warning
lamp
System
Select N (NEUTRAL) or P
(PARK) and apply the
parking brake until the transmission has cooled and the
message disappears from the
display.
red
Transmission malfunction
amber
Engagement in progress
Press brake pedal
Move shifter to P
Automatic transmission.
ESP malfunction
Warning
lamp
amber
106
System
Climate control
Air is directed through the evaporator
where it is cooled. Humidity is
extracted from the air to help keep
the windows free of mist. The
resulting condensation is directed to
the outside of the vehicle and it is
therefore normal if you see a small
pool of water under your vehicle.
PRINCIPLE OF
OPERATION
Outside air
Keep the air intakes forward of the
windscreen free from obstruction
(snow, leaves etc.) to allow the
climate control system to function
effectively.
General information on
controlling the interior
climate
Recirculated air
CAUTION
Prolonged use of recirculated air
may cause the windows to mist
up. If the windows mist up, follow the
settings for defrosting and demisting
the windscreen.
Heating
AIR VENTS
Air conditioning
Note: The air conditioning operates
only when the temperature is above
4C (39F).
E77930
107
Climate control
Temperature control
MANUAL CLIMATE
CONTROL
Air distribution control
A
F
E75471
Windscreen
Footwell
Face level
Cold
Red
Warm
Blower
E71379
Blue
E75470
Off
108
Climate control
Recirculated air
Air conditioning
Switching the air conditioning
on and off
Rapid windscreen
defrosting/demisting
Note: For the air conditioning to
operate the engine must be running.
Press the switch to turn on or off. The
lamp in the switch indicates when air
conditioning is selected.
E77937
E77935
Ventilation
E71380
109
Climate control
Rapid cooling of the vehicles
interior
E71381
Windscreen
defrosting/demisting
E71383
E71382
110
Climate control
AUTOMATIC CLIMATE CONTROL
E91390
111
Climate control
To switch mono mode back
on
Mono mode
In mono mode, the temperature
settings for both the drivers and
passengers side are linked. If you
adjust the temperature using the
rotary control on the drivers side, the
settings will be adjusted to the same
setting on the passengers side. In
mono mode, MONO appears in the
display.
Blower
Air distribution
To adjust air distribution, press the
desired button. Any combination of
settings can be selected
simultaneously.
112
Climate control
To return to auto mode, press the
AUTO button.
E70308
E91393
Footwell
Face level
Windscreen
Recirculated air
E91392
E91394
113
Climate control
Heated rear window
Heated windows
Heated windscreen
E78039
AUXILIARY HEATER
Programmable auxiliary
heater
WARNINGS
The programmable auxiliary
heater must not be operated in
enclosed spaces, at filling stations or
near sources of combustible vapours
or dust.
114
Climate control
Used properly, the programmable
auxiliary heater provides the following
benefits:
It preheats the interior of the
vehicle.
It keeps the windows clear of ice
in the event of frost and prevents
condensation.
It avoids cold starts and allows the
engine to reach operating
temperature sooner.
WARNINGS
The programmable auxiliary
heater should be switched on
for approximately 10 minutes at least
once a month all year round. This
prevents the water pump and heater
motor from seizing.
To avoid corrosion, the coolant
in your vehicle should contain at
least 10 % antifreeze all year round.
Note: The programmable auxiliary
heater will only operate if there is at
least 7.5 litres of fuel in the fuel tank.
115
Climate control
Auxiliary heater
ELECTRIC SUNROOF
E78054
WARNING
Before operating the electric
sunroof you should verify it is
free of obstructions and ensure that
children and/or pets are not in the
proximity of the sunroof opening.
Failure to do so could result in serious
personal injury. It is the primary
responsibility of the supervising adults
to never leave a child unattended in
a vehicle and to never leave the keys
in an unattended vehicle.
116
Climate control
Tilting the sunroof
E72189
B
A
E72185
E72188
Press to open
Press to close
A
E72185
Press to close
Press to open
117
Climate control
To open or close the sunroof
automatically press either side of the
switch to the second action point and
release it completely. Press again to
stop.
Sunroof anti-trap
protection
WARNING
The anti-trap function is not
active during this procedure.
Make sure that there are no
obstacles in the way of the closing
sunroof.
Sunroof relearning
WARNING
The anti-trap function is not
active during this procedure.
Make sure that there are no
obstacles in the way of the closing
sunroof.
118
Climate control
In case the sunroof no longer closes
properly, follow this relearning
procedure:
119
Seats
SITTING IN THE
CORRECT POSITION
E68595
WARNINGS
Do not adjust the seats when
the vehicle is moving.
MANUAL SEATS
E70728
120
Seats
Adjusting the angle of the
seatback
WARNING
Rock the seat backwards and
forwards after releasing the
lever to make sure that it is fully
engaged in its catch.
E70731
HEAD RESTRAINTS
Adjusting the head restraint
WARNINGS
Raise the rear head restraint
when the rear seat is occupied
by a passenger.
E70729
E70730
E66539
121
Seats
Adjust the head restraint so that the
top of it is level with the top of your
head.
ELECTRIC SEATS
2-way electric seat
E78059
122
Seats
6-way electric seat
E78060
123
Seats
REAR SEATS
Comfort seat system
WARNING
Make sure that there is nothing
in the luggage compartment
which could obstruct the movement
of the seats or get damaged when
the seats move rearwards.
The centre seat can be folded up and
the outboard seats moved rearwards
and slightly inboard to provide more
leg and shoulder room for the rear
passengers.
E78063
E78064
E78062
124
Seats
Folding the seatbacks
forward
WARNING
Do not fold the seatbacks
forward when the seats are in
the comfort position (slid rearwards).
This could result in damage to the
seats or panel trim. Slide the seats
fully forwards.
E78065
WARNING
E78066
125
Seats
Returning the seatbacks to
the upright position
E78068
WARNING
Always have the rear head
restraints raised when the rear
seat is occupied by a passenger or
a child restraint.
E78067
126
Seats
Folding the seats forward
All vehicles
E78069
E78071
WARNING
Always attach the bungee strap
to the front head restraint when
a rear seat is folded forwards. Failure
to do so may result in the seat falling
back down.
E78070
127
Seats
Once the seats are folded forward,
pull out and attach the bungee straps
to the front head restraints to hold
the folded seats in the upright
position.
E78072
WARNING
Always secure a seat with its
support when it is folded
forwards. Failure to do so may result
in the seat falling back down.
128
Seats
Returning the seats to the
seating position
WARNINGS
Make sure that the locking hole
on the floor is clear of sand, rock
or any objects which may prevent
the seat from locking.
All vehicles
E78074
E78073
WARNINGS
Make sure that no objects are
located in the storage
compartments under the rear seats
which could get damaged when the
seats are folded down.
129
Seats
Vehicles with seat supports
Slide the supports into the larger hole
on the base of the seats and detach
them. Fold the outboard seat
supports down and attach them to
the retainers on the floor. Detach the
centre seat support from the floor
and secure it in its retainer on the
floor under the right-hand seat.
E78075
All vehicles
WARNING
Make sure the seat is securely
locked by pushing forward and
rearward on the top of the seatback
or by trying to pull up the edge of the
cushion.
Fold the seats back down until they
engage.
Raise the seatbacks ensuring that
they engage in their latches.
Make sure the seatbelts will function
properly and are positioned in front
of the seatback.
The rear seatbelts should be placed
in the belt guides on the outboard
seatbacks.
E78076
WARNING
The rear seats are heavy. To
avoid injury, take care when
lifting the seats.
130
Seats
In order to remove the seats from the
retaining bar on the floor, the seat
should be held at an angle of
approximately 45 degrees to the
floor.
E78077
WARNINGS
Make sure that no objects are
located in the storage
compartments under the rear seats
which could get damaged when the
seats are folded down.
E78073
131
Seats
HEATED SEATS
E78061
WARNING
Heating with the engine off will
drain the battery.
The heated front seats are operated
by rotary controls in the instrument
panel.
The maximum temperature is
reached after five or six minutes. It is
regulated thermostatically.
The seat heating will operate only
when the ignition is in position II.
132
Convenience features
Panoramic roof
SUN VISORS
E72973
SUN BLINDS
Side windows
E91500
E78057
133
Convenience features
INSTRUMENT LIGHTING
DIMMER
AUXILIARY POWER
SOCKETS
CAUTION
If you use the socket when the
engine is not running, the battery
may discharge.
Note: You can use the socket to
power 12 volt appliances that have a
maximum current rating of 10
Amperes. Use only Ford accessory
connectors or connectors specified
for use with SAE standard sockets.
E70454
CIGAR LIGHTER
E78055
E78056
WARNING
Power inverter
CAUTIONS
If you use the socket when the
engine is not running, the battery
may discharge.
134
Convenience features
The following features are
incorporated into the centre console:
Front and rear storage
compartments.
Ashtray. To empty, pull out the
complete ashtray.
Cigar lighter. See Cigar lighter
(page 134).
Cup holders.
Auxiliary input (AUX IN) socket.
See Auxiliary input (AUX IN)
socket (page 140).
Storage box.
CAUTIONS
Do not exceed the maximum
power output. If you do, the LED
will flash twice. Remove the plug and
re-insert it.
If the LED flashes 3 or 4 times,
have the system checked by a
properly trained technician.
Storage box
E98199
CENTRE CONSOLE
Front seat centre console
WARNINGS
Do not place hot drinks in the
cup holders when the vehicle is
moving.
E73704
135
Convenience features
E72905
E72905
E78102
WARNING
Close the lid of the console
before installing it.
Fold up the rear centre seat. See
Rear seats (page 124).
E78101
136
Convenience features
WARNING
Close the lid of the console
before removing it.
Press the locking handle under the
front of the console 5, pull the
console up at the front edge and lift
it out 6.
COOL BOX
E78103
E78162
STORAGE
COMPARTMENTS
Front storage compartment
E78104
E92189
137
Convenience features
Storage area under the
rear centre seat
WARNING
Never drive with the front
storage compartment lid open.
This will obscure your vision out of
the windscreen. Before setting off,
always ensure that the lid is securely
engaged.
Note: Avoid keeping heat-sensitive
objects and liquids in the front
storage compartment.
E78094
138
Convenience features
E72630
E91508
TOLL READER
GLASSES HOLDER
E75193
E78729
139
Convenience features
Type 2
CHILDMINDER MIRROR
E91511
E75192
Type 1
E92035
E91510
140
IGNITION SWITCH
E78086
141
Positon II
STARTING A PETROL
ENGINE
All vehicles
WARNING
If the engine does not start,
refer to the instructions
regarding the fuel cut-off switch. See
Fuel cut-off switch (page 175).
Postion III
Starter motor activated. Release the
key as soon as the engine starts.
142
Cold/hot engine
WARNING
Flooded engine
Depress the clutch pedal fully.
Slowly depress the accelerator fully,
hold it in this position and start the
engine.
If the engine does not start repeat
the Cold/hot engine procedure.
143
All vehicles
Push the ignition switch in and turn it
to switch on the ignition and to start
the engine.
STARTING A DIESEL
ENGINE
Cold/hot engine
Depress the clutch pedal without
touching the accelerator.
Turn the key to position II
and ensure the glow plug
indicator lamp illuminates.
E87381
144
E78300
E78301
KEYLESS STARTING
WARNINGS
The keyless starting system
may not function if the key is
close to metal objects or electronic
devices such as mobile phones.
145
WARNINGS
Always check that the steering
wheel lock is deactivated before
attempting to move your vehicle.
See Cigar lighter (page 134).
CAUTION
Release the start button as soon
as the engine starts.
Note: Releasing the start button or
the clutch pedal during engine start
will stop the engine cranking and
return to ignition on.
1. Fully depress the clutch pedal.
2. Press the start button.
E85766
146
Type 2
E87381
E87382
E85767
147
E97918
ENGINE HEATER
CAUTION
Make sure you disconnect the
power cable from the engine
heater connector before driving
away.
Note: Only use the engine heater in
temperatures below -10C (14F).
148
WARNINGS
Stop refuelling after the fuel
nozzle stops the second time.
Additional fuel will fill the expansion
space in the fuel tank which could
lead to fuel overflowing. Fuel spillage
could be hazardous to other road
users.
WARNINGS
Do not modify the fuel system
configuration or the
components in the system.
Do not replace the fuel system
or the components with parts
not specially designed to be used
with bio ethanol.
CAUTIONS
Do not use leaded petrol or
petrol with additives containing
other metallic compounds (e.g.
manganese-based). They could
damage the emission system.
CAUTION
149
CATALYTIC CONVERTER
Driving with a catalytic
converter
CAUTIONS
Avoid running out of fuel.
Long-term storage
Due to small amounts of corrosive
impurities that may be found in the
bio ethanol E 85, it is recommended
that you fill the tank with only 95
octane unleaded petrol prior to
long-term storage of your vehicle.
Parking
WARNING
WARNING
CAUTION
Do not add kerosene, paraffin or
petrol to diesel. This could cause
damage to the fuel system.
Note: We do not recommend the
prolonged use of additives intended
to prevent fuel waxing.
Use diesel that meets the
specification defined by EN 590, or
equivalent.
You can use diesel that contains up
to 5% RME (bio diesel).
150
REFUELLING
CAUTION
Do not attempt to start the
engine if you have filled the fuel
tank with the incorrect fuel. This could
damage the engine. Have the system
checked by a properly trained
technician immediately.
E78089
FUEL CONSUMPTION
151
Extraurban
Combined
CO2 emissions
l/100 km
(mpg)
l/100 km
(mpg)
l/100 km
(mpg)
g/km
8.9 (31.7)
5.7 (49.6)
6.9 (40.9)
164
8.9 (31.7)
5.5 (51.4)
6.8 (41.5)
162
9.6 (29.4)
5.6 (50.4)
7.1 (39.8)
169
10.6 (26.6)
6.0 (47.1)
7.7 (36.7)
184
5.6 (50.4)
7.3 (38.7)
174
6.2 (45.6)
8.1 (34.9)
194
1.6 l Duratorq-TDCi 66
kW (90 PS), Stage IV,
Axle ratio: 3.41
6.0 (47.1)
4.1 (68.9)
4.8 (58.9)
127
1.6 l Duratorq-TDCi 80
kW (109 PS), Stage III/IV,
Axle ratio: 3.41
6.3 (44.8)
4.1 (68.9)
4.9 (57.6)
129
1.6 l Duratorq-TDCi 80
kW (109 PS), Stage III,
Durashift CVT, Axle ratio:
4.33
7.1 (39.8)
4.9 (57.6)
5.7 (49.6)
153
Variant
152
Extraurban
Combined
CO2 emissions
l/100 km
(mpg)
l/100 km
(mpg)
l/100 km
(mpg)
g/km
1.6 l Duratorq-TDCi 80
kW (109 PS), Stage IV
with a DPF, Durashift
CVT, Axle ratio: 4.33
7.4 (38.2)
4.9 (57.6)
5.8 (48.7)
154
1.8 l Duratorq-TDCi,
Stage IV, Axle ratio: 3.41
6.9 (40.9)
4.5 (62.8)
5.4 (52.3)
143
2.0 l Duratorq-TDCi,
Stage III, Axle ratio: 4.07
(2.85 in 5th/6th)
7.5 (37.7)
4.5 (62.8)
5.6 (50.4)
148
2.0 l Duratorq-TDCi,
Stage IV, Axle ratio: 4.07
(2.85 in 5th/6th)
7.6 (37.2)
4.8 (58.9)
5.8 (48.7)
154
Variant
153
Transmission
Reverse gear 6-speed
transmission
MANUAL TRANSMISSION
WARNINGS
Engage reverse gear only when
the vehicle is stationary.
Do not apply any undue lateral
force to the gear lever when
changing from 5th to 4th gear as this
could lead to the inadvertent
selection of 2nd gear.
2
1
E75052
AUTOMATIC
TRANSMISSION
General information
This transmission also allows you to
change gear manually (similar to a
manual transmission).
E75050
154
Transmission
Selector lever positions
Park
WARNINGS
Select park only when your
vehicle is stationary.
Apply the parking brake
and select park before
leaving your vehicle. Make sure
that the selector lever is latched in
position.
Note: An audible warning will sound
if you open the driver's door and you
have not selected park.
Note: The battery saver will
deactivate the warning chime after a
period of time.
E78310
Park
Reverse
Neutral
Drive
Manual shifting
Reverse
WARNING
WARNING
155
Transmission
Hints on driving with an
automatic transmission
Drive
Select drive to shift automatically
through the forward gears.
Moving off
Manual shifting
WARNING
WARNING
Stopping
Kickdown
Press the accelerator pedal fully with
the selector lever in the drive position
to select the next lowest gear for
optimum performance. Release the
accelerator pedal when you no
longer require kickdown.
Drive modes
156
Transmission
With a suitable object push down the
locking lever in the slot and
simultaneously move the selector
lever out of the P position.
Note: If position P is selected again,
this procedure must be repeated.
E78321
CAUTION
Take care when lifting up the
hinged cover.
Lift up the hinged cover in the centre
console next to the selector lever
with a small flat bladed tool.
E78322
157
Brakes
Wet brake discs result in reduced
braking efficiency. Dab the brake
pedal when driving from a car wash
to remove the film of water.
PRINCIPLE OF
OPERATION
Dual circuit braking system
ABS
WARNING
The ABS does not relieve you of
your responsibility to drive with
due care and attention.
The ABS helps you to maintain full
steering and directional stability when
you brake heavily in an emergency,
by preventing the road wheels from
locking. The ABS monitors the speed
of each road wheel and varies the
pressure to each brake. The ABS
optimizes the tyre-to-road adhesion
when you brake heavily.
E71353
WARNING
If a brake circuit fails, you will
notice a softer feel to the brake
pedal. Press the brake pedal firmly
and allow for increased stopping
distances. Stop and have this
checked immediately. Do not
continue your journey.
Disc brakes
E71355
E71354
158
Brakes
PARKING BRAKE
All vehicles
E70430
WARNING
Vehicles with an automatic
transmission should always be
left with the selector lever in position
P.
159
Stability control
The system also provides an
enhanced traction control function
by reducing engine torque if the
wheels spin when you accelerate.
This improves your ability to pull away
on slippery roads or loose surfaces,
and improves comfort by limiting
wheel spin in hairpin bends.
PRINCIPLE OF
OPERATION
Electronic stability
programme (ESP)
WARNING
ESP does not relieve you of your
responsibility to drive with due
care and attention.
B
A
A
E72903
without ESP
with ESP
160
Stability control
USING STABILITY
CONTROL
E78085
161
Parking aid
PRINCIPLE OF
OPERATION
WARNING
The parking aid does not relieve
you of your responsibility to
drive with due care and attention.
CAUTIONS
The sensors may not detect
objects in heavy rain or other
conditions that cause disruptive
reflections.
162
Parking aid
Manoeuvring with the
parking aid
E72902
CAUTIONS
The parking aid does not detect
obstacles moving away from the
vehicle. They will only be detected
shortly after they start to move
towards the vehicle again.
Take particular care when
reversing with a tow ball arm or
rear fitted accessories e.g. a bicycle
carrier, as the rear parking aid will only
indicate the distance from the
bumper to the obstacle.
Note: If a high pitch warning tone
sounds for three seconds and the
light in the switch is flashing, it
indicates a malfunction. The system
will be disabled. Have the system
checked by properly trained
technicians.
163
Cruise control
Setting a speed
PRINCIPLE OF
OPERATION
Cruise control allows you to control
your speed using the switches on the
steering wheel. You can use cruise
control when you exceed 40 km/h
(25 mph).
E75452
164
Cruise control
Resuming the set speed
A
B
E95393
Accelerate
E75453
Decelerate
E75453
E75455
165
166
Load carrying
GENERAL INFORMATION
LUGGAGE COVERS
WARNINGS
Use load securing straps to an
approved standard, e.g. DIN.
Make sure that you secure all
loose items properly.
Place luggage and other loads
as low and as far forward as
possible within the luggage or
loadspace.
Do not drive with the tailgate or
rear door open. Exhaust fumes
may enter the vehicle.
E78092
WARNING
Do not place objects on the
luggage cover.
E97377
167
Load carrying
REAR UNDER FLOOR
STORAGE
E78097
168
Towing
Change down a gear before you
reach a steep downhill gradient.
TOWING A TRAILER
WARNINGS
Do not exceed the maximum
vehicle and trailer weight stated
on the vehicle identification plate. See
Vehicle identification (page 226).
E71328
WARNING
The tow ball arm must be stored
securely in the luggage
compartment at all times when
detached.
Steep gradients
WARNING
The overrun brake on a trailer is
not controlled by ABS.
169
Towing
Unlocking the tow ball arm
mechanism
3
1
1
2
E71329
WARNING
Do not use any tools for
mounting or dismounting the
tow ball arm. Do not modify the trailer
coupling. Do not disassemble or
repair the tow ball arm.
2
E71330
WARNINGS
Special care should be taken
when fitting the tow ball arm, as
the safety of the vehicle and the
trailer depends on this.
170
Towing
3
A
2
B
E71331
WARNING
E71332
171
Towing
Insert the plug into its seat.
E71333
WARNING
To avoid risk of injury, never
unlock the towball arm with the
trailer attached.
If not in use for longer periods of time,
lock the mechanism. Push the lever
forwards.
Maintenance
WARNING
Remove the tow ball arm and
protect the seat with the plug
before steam cleaning your vehicle.
Keep the system clean. Periodically
lubricate the lock with graphite.
Keep a note of the key number.
172
Driving hints
RUNNING-IN
Tyres
WARNING
New tyres need to be run-in for
approximately 500 kilometres
(300 miles). During this time, you may
experience different driving
characteristics.
Engine
CAUTION
Avoid driving too fast during the
first 1 500 kilometres (1 000
miles). Vary your speed frequently
and change up through the gears
early. Do not labour the engine.
173
Emergency equipment
Right-hand drive
E78363
WARNING TRIANGLE
Left-hand drive
E78362
174
WARNING
INSPECTING SAFETY
SYSTEM COMPONENTS
Seat belts
E72531
175
Fuses
Right-hand drive
E78330
E78329
E78332
176
Fuses
Central fuse box
WARNINGS
Switch the ignition and all
electrical equipment off before
touching or attempting to change a
fuse.
CAUTION
Fit a replacement fuse with the
same rating as the one you have
removed.
E78331
FUSE LABELS
The fuse chart label shows
rectangles representing a fuse or
relay. The following information is
shown in the rectangles:
CHANGING A FUSE
WARNINGS
Do not modify the electrical
system of your vehicle in any
way. Have repairs to the electrical
system and the replacement of
relays and high current fuses carried
out by properly trained technicians.
177
Fuses
Engine management or
electronic module
Heater blower
Heated windscreen
PTC heater (vehicles with a
diesel engine)
Injectors, ignition
transformers
Headlamp washer
E78342
Horn
Diesel fuel heater
Air conditioning
Power steering
Battery sense smart
charging
Diesel pre-glow
178
Fuses
FUSE SPECIFICATION CHART
Engine junction box
29
36
28
35
11
13
15
22
20
19
2
1
E79716
Fuse
Ampere
rating
50
Cooling fan
80
Power steering
60
60
80
Climate control
60
30
20
20
Circuits protected
179
27
32
25
31
33
30
16
26
14
24
12
21
10
17
23
18
34
Fuses
Fuse
Ampere
rating
10
30
11
20
Ignition switch
12
40
13
20
Starter solenoid
14
40
15
30
16
40
17
Not used
18
Not used
19
10
ABS module
20
15
Horn
21
20
Auxiliary heater
22
10
23
30
Headlamp washer
24
15
25
10
Ignition, relays
26
10
Automatic transmission
27
10
28
10
29
10
30
31
10
32
10
Automatic transmission
33
10
Circuits protected
180
Fuses
Fuse
Ampere
rating
33
10
34
10
35
10
36
10
Circuits protected
129
135
100
101
136
123
137
134
133
132
130
138
141
139
142
140
143
131
117
124
125
119
120
127
128
126
111
118
121
115
116
122
105
106
107
109
110
108
113
104
114
103
112
102
E88709
Fuse
Ampere rating
Circuits protected
100
10
101
20
181
Fuses
Fuse
Ampere rating
Circuits protected
102
10
103
10
104
10
105
25
106
107
10
Instrument cluster
battery supply, on-board
diagnostics
108
7.5
Accessory to cluster
(audio and navigation
unit)
109
20
110
10
111
15
Fuel pump
112
15
113
10
114
10
115
7.5
182
Not used
Fuses
Fuse
Ampere rating
116
20
Fog lamps
117
7.5
118
20
119
25
120
20
121
20
122
10
Airbag module
123
7.5
124
7.5
125
7.5
126
20
127
25
Electric windows,
cooling unit
128
129
20
130
131
15
132
15
Brake lamps
133
25
183
Circuits protected
Not used
Windscreen wipers
Not used
Fuses
Fuse
Ampere rating
134
20
135
20
136
15
137
10
138
10
Powertrain control
module, accelerator
pedal, automatic transmission
139
10
140
10
141
10
142
15
143
15
184
Circuits protected
Vehicle recovery
The towing eye must always be
carried in the vehicle.
TOWING POINTS
CAUTION
The screw-in towing eye has a
left-hand thread. Turn it
anti-clockwise to install it. Use the
wheelbrace to make sure that the
towing eye is fully tightened.
E78366
E91637
E89126
185
Vehicle recovery
Note: On vehicles with a tow bar,
the towing eye cannot be installed at
the rear of the vehicle. Use the tow
bar to tow a vehicle.
E78367
CAUTIONS
Too much tension in the tow
rope could cause damage to
your vehicle or the vehicle that is
towing.
Do not use a rigid tow bar on the
front towing eye.
Drive off slowly and smoothly without
jerking the vehicle that is towing.
E78368
186
Vehicle recovery
Vehicles with automatic
transmission
CAUTIONS
Do not tow your vehicle faster
than 50 km/h (30 mph) or further
than 50 kilometres (30 miles). On
vehicles with a 6DCT450
transmission, do not tow your vehicle
faster than 30 km/h (18 mph).
If the stated speed or distance is
to be exceeded the drive wheels
must be lifted clear of the ground.
In the event of a mechanical
failure of the transmission the
drive wheels must be lifted clear of
the ground.
Do not tow your vehicle
backwards.
Select neutral when your vehicle
is being towed.
187
Maintenance
Check when refuelling
GENERAL INFORMATION
Monthly checks
WARNINGS
Switch the ignition off before
touching or attempting
adjustment of any kind.
Daily checks
Exterior lamps.
Interior lamps.
Warning lamps and indicators.
188
Maintenance
OPENING AND CLOSING
THE BONNET
Opening the bonnet
WARNING
To prevent damage to, or loss
of the key, remove the key
immediately after opening and swivel
the Ford badge back.
1
E78143
E78141
E78142
189
Maintenance
ENGINE COMPARTMENT OVERVIEW - 1.6L DURATEC16V (SIGMA)/1.6L DURATEC-16V TI-VCT (SIGMA)
A
E78887
Brake and clutch fluid reservoir (right-hand drive) : See Brake and
clutch fluid check (page 202).
Engine oil filler cap : See Engine oil check (page 200).
190
Maintenance
*
Brake and clutch fluid reservoir (left-hand drive) : See Brake and
clutch fluid check (page 202).
For easy identification, filler caps and the engine oil dipstick are marked in
colour.
191
Maintenance
ENGINE COMPARTMENT OVERVIEW - 1.8L DURATECHE (MI4)/2.0L DURATEC-HE (MI4)
A
E78889
Brake and clutch fluid reservoir (right-hand drive) : See Brake and
clutch fluid check (page 202).
Engine oil filler cap : See Engine oil check (page 200).
192
Maintenance
*
Brake and clutch fluid reservoir (left-hand drive) : See Brake and
clutch fluid check (page 202).
For easy identification, filler caps and the engine oil dipstick are marked in
colour.
193
Maintenance
ENGINE COMPARTMENT OVERVIEW - 1.6L
DURATORQ-TDCI (DV) DIESEL
A
E78891
Brake and clutch fluid reservoir (right-hand drive) : See Brake and
clutch fluid check (page 202).
Engine oil filler cap : See Engine oil check (page 200).
194
Maintenance
*
Brake and clutch fluid reservoir (left-hand drive) : See Brake and
clutch fluid check (page 202).
For easy identification, filler caps and the engine oil dipstick are marked in
colour.
195
Maintenance
ENGINE COMPARTMENT OVERVIEW - 1.8L
DURATORQ-TDCI (LYNX) DIESEL
A
E78892
Brake and clutch fluid reservoir (right-hand drive) : See Brake and
clutch fluid check (page 202).
Engine oil filler cap : See Engine oil check (page 200).
196
Maintenance
*
Brake and clutch fluid reservoir (left-hand drive) : See Brake and
clutch fluid check (page 202).
For easy identification, filler caps and the engine oil dipstick are marked in
colour.
197
Maintenance
ENGINE COMPARTMENT OVERVIEW - 2.0L
DURATORQ-TDCI (PUMA) DIESEL
A
E78893
Brake and clutch fluid reservoir (right-hand drive) : See Brake and
clutch fluid check (page 202).
Engine oil filler cap : See Engine oil check (page 200).
198
Maintenance
*
Brake and clutch fluid reservoir (left-hand drive) : See Brake and
clutch fluid check (page 202).
For easy identification, filler caps and the engine oil dipstick are marked in
colour.
E95540
E92036
MIN
MIN
MAX
MAX
199
Maintenance
ENGINE OIL DIPSTICK 1.6L DURATORQ-TDCI
(DV) DIESEL
A
E95543
E90983
MIN
MAX
MIN
MAX
CAUTION
Do not use oil additives or other
engine treatments. Under certain
conditions, they could damage the
engine.
Note: The oil consumption of new
engines reaches its normal level after
approximately 5 000 kilometres (3
000 miles).
MIN
MAX
CAUTION
Make sure that the level is
between the MIN and the MAX
marks.
Note: Check the level before starting
the engine.
200
Maintenance
Note: Make sure that your vehicle
is on level ground.
ENGINE COOLANT
CHECK
Topping up
WARNINGS
Only top up when the engine is
cold. If the engine is hot, wait 10
minutes for the engine to cool down.
E75521
CAUTION
Make sure that the coolant level
is between the MIN and the
MAX marks.
CAUTION
Do not top up further than the
MAX mark.
201
Maintenance
WARNINGS
Only add coolant when the
engine is cold. If the engine is
hot, wait 10 minutes for the engine to
cool down.
Do not allow coolant to touch
your skin or eyes. If this
happens, rinse the affected areas
immediately with plenty of water and
contact your doctor.
CAUTION
Do not spill coolant on any part
of the engine.
Only add coolant that meets the Ford
specification. See Technical
specifications (page 204).
WARNING
Do not allow brake fluid to touch
your skin or eyes. If this
happens, rinse the affected areas
immediately with plenty of water and
contact your doctor.
The brake and the clutch systems
are supplied from the same reservoir.
Make sure that the brake fluid level
is between the MIN and the MAX
marks.
E73701
E78897
202
Maintenance
If it drops below the MIN mark, top
up with the specified fluid. See
Technical specifications (page
204).
Vehicles with 1.8L DuratecHE (MI4) or 2.0L DuratecHE (MI4) or 2.5L DuratecST (VI5) or 1.6L DuratorqTDCi (DV) Diesel or 1.8L
Duratorq-TDCi (Kent) Diesel
or 2.0L Duratorq-TDCi
(Kent) Diesel engine
No fluid level checks are necessary.
E78898
203
Maintenance
TECHNICAL SPECIFICATIONS
Vehicle fluids
Item
Engine oil
Recommended fluid
Ford or Motorcraft
Formula E SAE 5W-30
Engine Oil
Specification
WSS-M2C913-B
Ford or Motorcraft
Power Steering Fluid
WSS-M2C204-A2
Antifreeze
Motorcraft SuperPlus
Antifreeze
WSS-M97B44-D
Brake fluid
ESD-M6C57-A
You can use an alternative SAE 5W-30 engine oil, providing it meets the
specification defined by WSS-M2C913-B.
Note: If you operate your vehicle in temperatures below -20C, you must
not use SAE 10W-40 engine oil.
Topping up the oil: If you are unable to find an oil that meets the
specification defined by WSS-M2C913-B, you must use SAE 5W-30
(preferred), SAE 5W-40 (except Flexfuel vehicles) or SAE 10W-40 that
meets the specification defined by either ACEA A1/B1 (preferred) or ACEA
A3/B3. Using these oils can result in longer engine cranking periods, reduced
engine performance, reduced fuel economy and increased emission levels.
Capacities
Item
Capacity in litres
(gallons)
All
MAX-mark
Fuel tank
55 (12.1)
Fuel tank
55 (12.1)
Variant
204
Maintenance
Variant
Item
Capacity in litres
(gallons)
All
Windscreen washer
system
4.0 (0.9)
1.6L Duratec-16V
4.1 (0.9)
1.6L Duratec-16V
3.75 (0.8)
1.6L Duratec-16V
5.5 (1.2)
1.6L Duratec-16V
5.8 (1.3)
4.1 (0.9)
3.75 (0.8)
6.0 (1.3)
1.8L Duratec-HE
4.3 (0.9)
1.8L Duratec-HE
3.9 (0.9)
1.8L Duratec-HE
6.5 (1.4)
2.0L Duratec-HE
4.3 (0.9)
2.0L Duratec-HE
3.9 (0.9)
2.0L Duratec-HE
6.3 (1.4)
1.6L Duratorq-TDCi
3.8 (0.8)
1.6L Duratorq-TDCi
3.4 (0.7)
1.6L Duratorq-TDCi
7.3 (1.6)
1.8L Duratorq-TDCi
5.6 (1.2)
205
Maintenance
Item
Capacity in litres
(gallons)
1.8L Duratorq-TDCi
5.0 (1.1)
1.8L Duratorq-TDCi
8.1 (1.8)
2.0L Duratorq-TDCi
5.5 (1.2)
2.0L Duratorq-TDCi
5.0 (1.1)
2.0L Duratorq-TDCi
8.4 (1.8)
Variant
206
Vehicle care
Cleaning the rear window
CLEANING THE
EXTERIOR
CAUTION
Do not scrape the inside of the
rear window or use abrasives or
chemical solvents to clean it.
WARNING
If you use a car wash with a
waxing cycle, make sure that
you remove the wax from the
windscreen.
CAUTIONS
Some car wash installations use
water at high pressure. This
could damage certain parts of your
vehicle.
Body paintwork
preservation
CAUTIONS
Do not polish your vehicle in
strong sunshine.
CAUTIONS
Do not scrape the headlamp
lenses or use abrasives or
chemical solvents to clean them.
207
Vehicle care
CLEANING THE INTERIOR
Seat belts
WARNINGS
Do not use abrasives, or
chemical solvents to clean
them.
208
Vehicle battery
To connect the booster
cables
BATTERY CARE
The battery requires very little
maintenance. The fluid level is
checked regularly during the routine
service inspections.
USING BOOSTER
CABLES
CAUTIONS
Connect batteries with only the
same nominal voltage.
Always use booster cables with
insulated clamps and adequate
size cable.
E75183
209
Vehicle battery
C
CAUTIONS
Do not connect to the
negative () terminal of the
flat battery.
Make sure that the jump leads
are clear of any moving parts.
210
GENERAL INFORMATION
WARNINGS
Use only approved wheel and
tyre sizes. Using other sizes
could damage the vehicle and will
make the National Type Approval
invalid.
CAUTIONS
Use only approved wheel and
tyre sizes. Using other sizes
could damage the vehicle and will
make the National Type Approval
invalid.
WARNINGS
If the spare wheel differs from
the other fitted wheels, these
rules must be followed:
CHANGING A ROAD
WHEEL
Spare wheel
Your vehicle is equipped with either
a spare wheel or a tyre repair kit
(ContiMobilityKit). See Tyre repair
kit (page 217).
211
Vehicle jack
WARNINGS
The vehicle jack supplied with
your vehicle should only be used
when changing a wheel in
emergency situations.
All vehicles
Note: The spare wheel is located
under the floor cover in the luggage
compartment.
E72563
E72564
212
E78134
E78135
213
A
B
E92658
Maintenance
Indentations in the sills A show the
location of the jacking points.
E93184
214
E92932
Removing a wheel
All vehicles
CAUTION
WARNINGS
Park your vehicle in such a
position that neither the traffic
nor you are hindered or endangered.
215
All vehicles
1. Slacken the wheel nuts.
2. Place the jack with the whole foot
area on firm ground.
3. Jack up the vehicle until the wheel
is clear of the ground.
4. Unscrew and remove the wheel
nuts and take off the wheel.
E78139
Fitting a wheel
All vehicles
Note: Make sure that you use the
correct wheel nut for the type of
wheel, if in doubt check with your
dealer.
1. Push the wheel onto the wheel
studs.
2. Screw on the wheel nuts and
secure in a clockwise direction
ensuring that the tapered end of
the wheel nuts is facing the wheel.
3. Lower the vehicle and remove the
jack.
Vehicles with locking wheel
nuts
E72572
216
All vehicles
WARNINGS
Depending on the type and
extent of tyre damage, some
tyres can only be partially sealed or
not sealed at all. Loss of tyre
pressure can affect vehicle handling,
leading to loss of vehicle control.
Do not use the tyre repair kit if
the tyre has already been
damaged as a result of being driven
under inflated.
Do not try to seal damage other
than that located within the
visible tread of the tyre.
E72573
217
CAUTION
Do not keep the compressor
operating for more than 10
minutes.
218
CAUTION
Screwing the bottle onto the
bottle holder will pierce the seal
of the bottle. Do not unscrew the
bottle from the holder as the sealant
will escape.
219
B
J
C
I
D
H
E
G
F
E94973
Protective cap
Hose
Orange cap
220
Bottle holder
Pressure gauge
Compressor switch
Label
Bottle lid
Sealant bottle
221
222
TYRE CARE
E70415
223
TECHNICAL SPECIFICATIONS
Wheel nut torque
130 Nm
130 Nm
130 Nm
Full load
Front
Rear
Front
Rear
bar
(lbf/in)
bar
(lbf/in)
bar
(lbf/in)
bar
(lbf/in)
T125/85 R
162
4.2
4.2
4.2
4.2
All
195/65 R 15
2.1
2.3
2.4
2.8
All
225/40 R 18
2.3
2.3
2.4
2.8
Vehicles with a
petrol engine
205/55 R 16
2.1
2.3
2.4
2.8
Vehicles with a
petrol engine
205/50 R 17
2.1
2.3
2.4
2.8
Vehicles with a
diesel engine
205/55 R 16
2.3
2.3
2.4
2.8
Variant
All - temporary
spare tyre - 80
km/h (50 mph)
MAX
Tyre size
224
Vehicles with a
diesel engine
Tyre size
205/50 R 17
Full load
Front
Rear
Front
Rear
bar
(lbf/in)
bar
(lbf/in)
bar
(lbf/in)
bar
(lbf/in)
2.3
2.3
2.4
2.8
Tyre size
Full load
Front
Rear
Front
Rear
bar
(lbf/in)
bar
(lbf/in)
bar
(lbf/in)
bar
(lbf/in)
All
195/65 R 15
2.3
2.3
2.6
3.0
All
225/40 R 18
2.5
2.3
2.6
3.0
Vehicles with a
petrol engine
205/55 R 16
2.3
2.3
2.6
3.0
Vehicles with a
petrol engine
205/50 R 17
2.3
2.3
2.6
3.0
Vehicles with a
diesel engine
205/55 R 16
2.5
2.3
2.6
3.0
Vehicles with a
diesel engine
205/50 R 17
2.5
2.3
2.6
3.0
225
Vehicle identification
VEHICLE IDENTIFICATION
PLATE
B
VEHICLE IDENTIFICATION
NUMBER (VIN)
E85610
E87496
226
Vehicle identification
ENGINE NUMBER - 1.6L
DURATORQ-TDCI (DV)
DIESEL/2.0L DURATORQTDCI (PUMA) DIESEL
The engine number is stamped on
the engine block, next to the oil filter
and the oil cooler.
227
Technical specifications
TECHNICAL SPECIFICATIONS
Vehicle dimensions
E78157
Item
A
B
C
D
Dimension description
Dimension in mm
(inches)
Maximum length
Wheelbase
2640 (103.9)
228
Technical specifications
Item
Dimension description
E
E
Dimension in mm
(inches)
Front track
Rear track
E78158
229
Technical specifications
Item
Dimension description
103 (4.1)
146 (5.7)
32 (1.3)
898 (35.4)
941 (37.0)
517 (20.4)
1034 (40.7)
400 (15.7)
443 (17.4)
699 (27.5)
742 (29.2)
230
Dimension in mm
(inches)
Telephone
Note: The mobile phone does not
switch off immediately after the
ignition key is turned off: the power
down delay is preset to 10 minutes.
The time period can be adjusted to
between 0 and 60 minutes. This,
depending on your mobile phone,
can be achieved by creating a
phonebook entry on your mobile
phone with the name Timer and the
required delay as it's number.
GENERAL INFORMATION
This section describes the functions
and features of the Bluetooth mobile
phone and voice control system.
The section covers the following
variations:
TELEPHONE SETUP
231
Telephone
2. Push the phone downwards until
a click is heard.
Phone
Mobile
Home
Office
Fax
E87688
Phonebook
After start up access to the
phonebook can be delayed for up to
two minutes.
Phonebook categories
Depending on your phonebook entry,
different categories can be displayed
in the audio or navigation unit.
For example:
M
Mobile
Office
Home
Fax
232
Telephone
Bond another Bluetooth
phone
Handling of phones
Cradle phone
BLUETOOTH SETUP
Before you can use your telephone
with your vehicle it must be bonded
to the vehicle telephone system.
233
Telephone
Note: A phone call will be
disconnected if the audio/navigation
system is switched off. If the ignition
key is turned to the off position the
phone call will remain in progress.
Compatibility of phones
CAUTION
As no common agreement
exists, mobile phone
manufacturers are able to implement
a variety of profiles in their Bluetooth
devices. Because of this, an
incompatibility can occur between
the phone and hands-free system,
which in some cases may significantly
degrade the system performance.
To avoid this situation, only
recommended phones should be
used. Please contact your dealer for
more details regarding the current
compatibility list.
TELEPHONE CONTROLS
Ending or rejecting calls
By pressing one of several function
buttons on the audio or navigation
unit (example: AM/FM,CD/AUX)
active calls can be ended or incoming
calls can be rejected.
Remote control
One of several different types of
remote control may be fitted to your
vehicle:
Voice and mode button
1
Voice button
Mode button
234
Telephone
Voice and accept/reject button
E87664
E87662
Voice button
Accept/Reject button
E87663
235
Telephone
Making a call
Dialling a number
Ending a call
Redialling a number
1. Press the PHONE or the call
accept button.
2. Press the MENU button.
3. Select the CALL OUT list or the
CALL IN list.
Note: If the active phone does not
provide a call out list, the last
outgoing call number/entry is
displayed.
4. Press the seek button on the
audio unit.
5. Press the PHONE or the call
accept button to dial the desired
phone number.
Redialling the last dialled
number
Note: This applies to only audio units
with a telephone keypad
1. Press the call accept button.
236
Telephone
2. Press the call accept button again
to display the last dialled number.
3. Press the call accept button a
third time to dial the number.
Handling a second
incoming call
237
Telephone
Using the audio unit menu
1. Press the PHONE or call accept
button.
2. Press the MENU button on the
audio unit.
3. Select the ACTIVE PHONE
option on the audio unit.
4. Scroll through the different stored
phones by using the seek buttons
to display the bonded phones.
5. Press the MENU button to select
the phone which is to be the
active phone.
Note: After bonding a Bluetooth
phone to the system, this becomes
the active phone.
Making a call
238
Telephone
Handling an incoming call
Ending a call
Handling a second
incoming call
Note: The second incoming call
function must be activated in your
phone.
If there is an incoming call, whilst
there is an ongoing call, a beep will
be heard and you will have the option
to end the active call and to accept
the incoming call.
239
Telephone
Accepting a second incoming
call
Second incoming calls can be
accepted by either:
240
Voice control
Note: The voice control system is
language specific. If you require the
system to operate in another
language please consult your dealer.
PRINCIPLE OF
OPERATION
Voice recognition enables operation
of the audio system without the need
to divert your attention from the road
ahead in order to change settings, or
receive feedback from the system.
System response
As you work through a voice session
the system will prompt you with a
beep tone each time the system is
ready to proceed.
Voice commands
All voice commands should be given
using a natural speaking voice, as if
speaking to a passenger or on the
phone. Your voice level should be
dependant on the surrounding noise
level inside or outside the vehicle but
do not shout.
Supported commands
The voice control system allows you
to control the following vehicle
functions:
phone
radio
Name tag
CD Player
climate control
navigation system.
241
Voice control
E87665
242
Voice control
Overview
"HELP"
a
"DISC"
"TRACK"
a) Can only be used with a CD changer.
b) Can be used as a shortcut.
Disc
If you have a CD changer you can
choose the disc number.
Steps
User says
System answer
"CD"
"CD"
"DISC"
"DISC <number>"
User says
System answer
"CD"
"CD"
243
Voice control
Steps
User says
System answer
"TRACK"
"TRACK <number>"
Radio
The radio voice commands support
the functionality of the radio and allow
you to tune radio stations by voice
control.
"RADIO"
"HELP"
"AM"
"FM"
a
"TUNE NAME"
"DELETE NAME"
"DELETE DIRECTORY"
"PLAY DIRECTORY"
"STORE NAME"
a) Can be used as a shortcut.
Tune frequency
This function allows you to tune your
radio by voice commands.
244
Voice control
Steps
User says
System answer
"RADIO"
"RADIO"
"AM"
"FREQUENCY PLEASE"
"FM"
"FREQUENCY PLEASE"
"<frequency>"
"TUNE <frequency>"
3
Store name
User says
System answer
"RADIO"
"RADIO"
"STORE NAME"
"STORE NAME"
"NAME PLEASE"
"<name>"
"<name>"
"STORING NAME"
"<name> STORED"
Tune name
This function allows you to call up a
stored radio station.
Steps
User says
System answer
"RADIO"
"RADIO"
"TUNE NAME"
"<name>"
"NAME PLEASE"
"TUNE <name>"
245
Voice control
Delete name
Steps
User says
System answer
"RADIO"
"RADIO"
"DELETE NAME"
"NAME PLEASE"
"<name>"
"DELETE <name>"
"CONFIRM YES OR NO"
"YES"
"DELETED"
"NO"
"COMMAND CANCELLED"
Play directory
This function allows you to let the
system tell you all of the stored radio
stations.
Steps
User says
System answer
"RADIO"
"RADIO"
"PLAY DIRECTORY"
"PLAY <DIRECTORY>"
Delete directory
This function allows you to delete all
stored radio stations at once.
Steps
User says
System answer
"RADIO"
"RADIO"
"DELETE DIRECTORY"
"DELETE DIRECTORY"
"CONFIRM YES OR NO"
"YES"
"NO"
"COMMAND CANCELLED"
246
Voice control
TELEPHONE COMMANDS
Phone
Your phone system allows you to
create an additional phonebook. The
stored entries can be dialled by voice
control. Phone numbers stored by
using voice control are stored on the
vehicle system and not in your
phone.
Overview
The overview below shows the
available voice commands of the
phone system. The following lists will
give further information about the
complete command menu.
"PHONE"
"HELP"
a, b
"MOBILE NAME"
"DIAL NUMBER"
"DIAL NAME"
"DELETE NAME"
"DELETE DIRECTORY"
"PLAY DIRECTORY"
"STORE NAME"
"REDIAL"
"ACCEPT CALLS"
"REJECT CALLS"
a) Can be used as a shortcut.
b) Only possible on mobiles which are connected by Bluetooth and fitted with
voice control and stored name tags.
247
Voice control
Create a phonebook
Store name
Steps
User says
System answer
"PHONE"
"PHONE"
"STORE NAME"
"STORE NAME"
"NAME PLEASE"
"<name>"
"<name>"
"STORING NAME"
"<name> STORED"
"NUMBER PLEASE"
"<phone number>"
"<phone number>"
"STORE"
"STORING NUMBER"
"<phone number>"
"NUMBER STORED"
Delete name
Stored names can also be deleted
from the directory.
Steps
User says
System answer
"PHONE"
"PHONE"
"DELETE NAME"
"NAME PLEASE"
"<name>"
"DELETE <name>"
"CONFIRM YES OR NO"
"YES"
"<name> DELETED"
"NO"
"COMMAND CANCELLED"
248
Voice control
Play directory
Steps
User says
System answer
"PHONE"
"PHONE"
"PLAY DIRECTORY"
"PLAY DIRECTORY"
Delete directory
This function allows you to delete all
entries in one go.
Steps
User says
System answer
"PHONE"
"PHONE"
"DELETE DIRECTORY"
"DELETE DIRECTORY"
"CONFIRM YES OR NO"
"YES"
"PHONE DIRECTORY
DELETED"
"NO"
"COMMAND CANCELLED"
Phone functions
Mobile name
This function allows you to access
phone numbers stored with a name
tag in your mobile phone.
Steps
User says
System answer
"PHONE"
"PHONE"
"MOBILE NAME"
a, b
249
Voice control
b) Only when the mobile phone is fitted with Bluetooth and voice control
(dependant on the mobile phone).
Dial number
Phone numbers can be dialled after
giving the name tag voice command.
Steps
User says
System answer
"PHONE"
"PHONE"
"DIAL NUMBER"
"NUMBER PLEASE"
"<phone number>"
"<phone number>
CONTINUE?"
"DIAL"
"DIALLING"
"CORRECTION"
User says
System answer
"PHONE"
"PHONE"
"DIAL NAME"
"<name>"
"DIAL <name>"
"CONFIRM YES OR NO"
"YES"
"DIALLING"
"NO"
"COMMAND CANCELLED"
"NAME PLEASE"
250
Voice control
Redial
Steps
User says
System answer
"PHONE"
"PHONE"
"REDIAL"
"REDIAL"
"CONFIRM YES OR NO"
"YES"
"DIALLING"
"NO"
"COMMAND CANCELLED"
User says
System answer
1
2
"NUMBER PLEASE"
"<numbers 1 to 9, zero, hash,
star>"
Main settings
Accept and reject calls
Calls can be accepted or rejected
using the Voice Control.
Steps
User says
System answer
"PHONE"
"PHONE"
"ACCEPT CALLS"
"ACCEPT CALLS"
251
Voice control
Steps
User says
System answer
"REJECT CALLS"
"REJECT CALLS"
Overview
NAVIGATION SYSTEM
COMMANDS
CLIMATE CONTROL
COMMANDS
Climate
The climate voice commands
supports the functionality of the fan
speed, temperature and mode
settings. Not all functions are
available on all vehicles.
"CLIMATE"
"HELP"
a
"FAN"
"DEFROSTING/DEMISTING ON"
"DEFROSTING/DEMISTING OFF"
"TEMPERATURE"
"AUTO MODE"
252
Voice control
Fan
Steps
User says
System answer
"CLIMATE"
"CLIMATE"
"FAN"
"MINIMUM"
"FAN MINIMUM"
"FAN <number>"
"MAXIMUM"
"FAN MAXIMUM"
User says
System answer
"CLIMATE"
"CLIMATE"
"DEFROSTING/DEMISTING
a
ON"
"DEFROSTING/DEMISTING
a
OFF"
"DEFROSTING/DEMISTING ON"
"DEFROSTING/DEMISTING
OFF"
User says
System answer
"CLIMATE"
"CLIMATE"
"TEMPERATURE"
253
"TEMPERATURE PLEASE"
Voice control
Steps
User says
System answer
"MINIMUM"
"TEMPERATURE MINIMUM"
"TEMPERATURE <number>"
"MAXIMUM"
"TEMPERATURE MAXIMUM"
User says
System answer
"CLIMATE"
"CLIMATE"
"AUTO MODE"
"AUTO MODE"
254
Appendices
TYPE APPROVALS
TYPE APPROVALS
Bluetooth/voice recognition
system - declaration of
conformity
Remote control
Type 1
E78380
255
Appendices
E78381
256
Appendices
Type 2
If the type approval of your remote
control is inspected, refer to the table
below. It is recommended that you
use the remote control only in the
countries listed.
E78382
257
Appendices
E78383
258
Appendices
Passive key
E78384
Engine immobiliser
If the type approval of your engine
immobilisation system is inspected,
refer to the table below.
259
Appendices
E78385
260
Appendices
E78386
Alarm
If the type approval of your anti-theft
alarm system is inspected, refer to
the list of official test numbers below.
E78387
261
Appendices
ELECTROMAGNETIC
COMPATIBILITY
WARNINGS
Your vehicle has been tested
and certified to European
legislations relating to
electromagnetic compatibility
(2004/104/EC). It is your responsibility
to ensure that any equipment you
have fitted complies with applicable
local legislations. Have any
equipment fitted by properly trained
technicians.
WARNINGS
Radio frequency (RF) transmitter
equipment (e.g. cellular
telephones, amateur radio
transmitters etc.) may only be fitted
to your vehicle if they comply with the
parameters shown in the table below.
There are no special provisions or
conditions for installations or use.
Do not mount any transceiver,
microphones, speakers, or any
other item in the deployment path of
the airbag system.
Do not fasten antenna cables
to original vehicle wiring, fuel
pipes and brake pipes.
Keep antenna and power
cables at least 100mm from any
electronic modules and airbags.
6
4
1
3
5
E85998
262
Appendices
Frequency
Band MHz
Antenna Positions
1 30
50 W
3, 8
30 54
50 W
2, 3
68 87.5
50 W
1, 2, 3, 4, 5
142 176
50 W
1, 2, 3, 4, 5
380 512
50 W
1, 2, 3, 4, 5
806 940
10 W (2 W )
1, 2, 3, 4, 5 (6 , 7 )
1200 1400
10 W
1710 1885
10 W (1 W )
1885 2025
2400 2500
1, 2, 3, 4, 5 (6 , 7 )
10 W (1 W )
1, 2, 3, 4, 5 (6 , 7 )
0.1 W
All positions
Only for GSM/3G cellular phones, with a patch antenna installed inside of the
front windscreen.
Note: After the installation of RF
transmitters, check for disturbances
from and to all electrical equipment
in the vehicle, both in the standby and
transmit modes.
Check all electrical equipment:
with the ignition ON
with the engine running
during a road test at various
speeds.
Check that electromagnetic fields
generated inside the vehicle cabin by
the transmitter installed do not
exceed human exposure limits
specified in EU directive 2004/40/EC.
263
264
Index
Audio control...................................55
Mode.....................................................56
Seek.......................................................56
Volume..................................................56
A/C
See: Climate control..........................107
See: Brakes.........................................158
Autolamps........................................65
Automatic climate control.............111
Air distribution......................................112
Blower...................................................112
Mono mode.........................................112
Recirculated air...................................113
Setting the temperature.....................111
Switching off the automatic climate
control...............................................113
Switching the air conditioning on and
off.......................................................113
To switch mono mode back on.......112
To switch mono mode off.................112
Windscreen defrosting and
demisting..........................................113
Accessories
See: Parts and accessories..................7
Air conditioning
See: Climate control..........................107
Air vents..........................................107
Alarm.................................................53
Appendices...................................255
Arming the alarm.............................53
Drive modes.......................................156
Emergency park position release
lever..................................................156
General information...........................154
Hints on driving with an automatic
transmission....................................156
Selector lever positions.....................155
Principle of operation........................166
Automatic transmission................154
Auxiliary heater...............................114
Auxiliary heater....................................116
Fuel operated heater.........................116
Programmable auxiliary heater........114
265
Type 1...................................................140
Type 2..................................................140
Index
Auxiliary power sockets...............134
Changing a bulb..............................74
Power inverter....................................134
Approach lamps...................................78
Central brake lamp...............................81
Footwell lamp.......................................83
Front fog lamps (Type 1).....................78
Front fog lamps (Type 2)....................79
Headlamps, side lamps, direction
indicators...........................................74
Interior and reading lamps..................81
Luggage compartment lamp............82
Number plate lamp..............................81
Rear lamps............................................80
Side repeater indicator on exterior
mirrors................................................77
Side repeaters......................................77
Vanity mirror lamps..............................82
B
Battery care...................................209
Bluetooth setup............................233
Compatibility of phones...................234
Handling of phones...........................233
Requirements for Bluetooth
connection.....................................233
Bonnet lock
See: Opening and closing the
bonnet..............................................189
Booster cables
See: Using booster cables..............209
Booster cushions............................23
Booster cushion..................................23
Booster seat.........................................23
Changing a fuse.............................177
Changing a road wheel.................211
Fitting a wheel.....................................216
Jacking and lifting points...................213
Removing a wheel.............................215
Spare wheel.........................................211
Vehicle jack.........................................212
Bulb changing
See: Changing a bulb..........................74
Car wash
See: Cleaning the exterior...............207
Catalytic converter........................150
Driving with a catalytic converter.....150
Parking.................................................150
Centre console..............................135
266
Index
Child seats........................................20
Child restraints for different mass
groups...............................................20
Cigar lighter....................................134
Cleaning the exterior....................207
Body paintwork preservation..........207
Cleaning the chrome trim................207
Cleaning the headlamps..................207
Cleaning the rear window................207
Climate control...............................107
Principle of operation.........................107
Climate................................................252
Coded keys.....................................52
Convenience features..................133
Coolant check
Electric seats..................................122
Electric sunroof...............................116
Cool box..........................................137
Cruise control.................................164
Principle of operation........................164
Cruise control
See: Using cruise control..................164
Electric windows.............................84
Anti-trap function.................................84
Driver's door switches........................84
Global opening and closing...............84
Opening and closing the windows
automatically.....................................84
Resetting the memory of the electric
windows............................................85
Safety switch for rear windows.........84
Direction indicators..........................71
Electromagnetic
compatibility................................262
Emergency equipment.................174
Engine compartment overview.........
267
Index
Engine coolant check...................201
Topping up the coolant.....................201
Engine heater.................................148
Engine immobiliser..........................52
G
Gauges.............................................88
Engine coolant temperature
gauge.................................................90
Fuel gauge............................................90
Principle of operation..........................52
Engine number....................................
Engine oil check............................200
Checking the oil level........................200
Topping up..........................................201
F
Fastening the seat belts.................31
First aid kit.......................................174
Foot pedals
See: Adjusting the pedals..................58
Gearbox
See: Transmission..............................154
H
Handbrake
See: Parking brake............................159
Fuel consumption
See: .....................................................152
Heated seats.................................132
Heated windows and mirrors......114
Fuel consumption..........................151
Fuel cut-off switch.........................175
Fuse labels......................................177
Fuses...............................................176
Fuse specification chart................179
Engine junction box...........................179
Passenger junction box.....................181
Heating
See: Climate control..........................107
I
Ignition switch.................................141
Ignition switch positions.....................141
Immobiliser
See: Engine immobiliser.....................52
Information displays........................96
General information.............................96
268
Index
Information messages.................103
Inspecting safety system
components.................................175
L
Lighting control................................64
Seat belts.............................................175
Headlamp flasher................................64
Home safe lighting..............................64
Lighting control positions...................64
Main and dipped beam......................64
Parking lamps.......................................64
Interior mirror...................................87
Introduction........................................7
ISOFIX anchor points......................24
Lighting.............................................64
Load carrying.................................167
General information...........................167
Locks................................................40
Luggage covers.............................167
Jump starting
Maintenance..................................188
Keyless entry...................................44
Air conditioning...................................109
Air distribution control........................108
Blower..................................................108
Rapid heating of vehicle interior......109
Rapid windscreen
defrosting/demisting.....................109
Recirculated air...................................109
Temperature control.........................108
Ventilation............................................109
General information...........................188
Technical specifications...................204
Keyless starting.............................145
Failure to start.....................................147
Ignition on............................................146
Starting a diesel engine.....................146
Starting with automatic
transmission....................................146
Starting with manual
transmission....................................146
Stopping the engine..........................148
Manual seats..................................120
269
Index
Manual transmission.....................154
Personalised settings.....................99
Message centre
See: Information displays...................96
Mirrors
See: Heated windows and mirrors...114
See: Windows and mirrors.................84
N
Navigation system
commands..................................252
O
Occupant protection......................27
Principle of operation..........................27
Oil check
See: Engine oil check.......................200
Quick start.........................................10
Parking aid......................................162
Principle of operation........................162
Parking aid
See: Using the parking aid................162
Parking brake.................................159
All vehicles...........................................159
Pedals...............................................58
270
Index
Rear under floor storage..............168
Rear window wiper and
washers..........................................61
Intermittent wipe..................................61
Rear window washer..........................62
Reverse gear wipe...............................61
Refuelling.........................................151
Remote control battery
General information............................141
Steering wheel................................55
Storage compartments................137
Drivers seat storage bin...................138
Front storage compartment............137
Storage area under the rear centre
seat...................................................138
Sun blinds.......................................133
Panoramic roof...................................133
Side windows.....................................133
Safety precautions........................149
Seat back trays..............................138
Seat belt height adjustment..........33
Seats...............................................120
Sitting in the correct position.......120
Snow chains
Sunroof
See: Electric sunroof..........................116
Sun visors.......................................133
Switching off the engine...............148
Vehicles with a turbocharger...........148
Symbols glossary..............................7
Speed control
See: Cruise control............................164
Stability control...............................160
Principle of operation........................160
Stability control
Technical specifications...............228
Technical specifications...................228
Starter switch
Telephone commands................247
Create a phonebook........................248
Main settings......................................251
Phone..................................................247
Phone functions................................249
271
Index
Telephone controls......................234
Ending or rejecting calls...................234
Remote control.................................234
U
Using booster cables...................209
Telephone setup...........................231
Bond another Bluetooth phone......233
Making a phone an active phone....232
Phonebook........................................232
Phonebook categories....................232
Placing your phone in the cradle.....231
Requirements for cradle
connection......................................231
Telephone.......................................231
General information...........................231
Telephone
See: Using the telephone.......................
See: Using the telephone.......................
Toll reader.......................................139
Towing a trailer...............................169
Steep gradients..................................169
Towing points.................................185
All vehicles...........................................186
Vehicles with automatic
transmission....................................187
Towing.............................................169
Transmission..................................154
Type approvals..............................255
Alarm....................................................261
Engine immobiliser............................259
Passive key........................................259
Remote control.................................255
Tyre care........................................223
Tyre repair kit..................................217
Checking the tyre pressure.............222
General information...........................217
Inflating the tyre..................................218
Using the tyre repair kit.....................218
Tyres
See: Wheels and tyres.......................211
V
Vehicle battery..............................209
Vehicle care...................................207
Vehicle identification number
(VIN)..............................................226
Vehicle identification plate...........226
Vehicle identification.....................226
Vehicle recovery............................185
272
Index
Ventilation
Washing
Vents
VIN
See: Vehicle identification number
(VIN).................................................226
General information............................211
Technical specifications...................224
W
Warning lamps and indicators......90
ABS warning lamp...............................90
Airbag warning lamp...........................90
Brake system and ABS warning
lamps..................................................91
Brake system warning lamp..............90
Cruise control indicator.......................91
Direction indicator................................91
Doors open warning lamp..................91
Engine systems fault warning
lamp....................................................91
Engine warning lamp...........................91
Front fog lamp indicator......................91
Frost warning lamp..............................92
Glow plug indicator.............................92
Headlamp indicator.............................92
Ignition warning lamp..........................92
Low fuel level warning lamp...............92
Main beam indicator...........................92
Maximum engine RPM warning
lamp...................................................92
Message indicator...............................92
Oil pressure warning lamp.................93
Power steering warning lamp...........93
Rear fog lamp indicator......................93
Seat belt reminder...............................93
Stability control (ESP) indicator..........93
Winter tyres
See: Using winter tyres....................223
Warning triangle.............................174
Washer fluid check.......................203
Washers
273
274
8M5J-19A321-BDA (CG3478en)