Material Safety Data Sheet
Used to comply with OSHA's Hazard
GSmmurication Standard, 29 CPA 1910.1200
SHERWIN INCORPORATED
5530 Borwick Aveune
‘South Gate, California 90280
562.861.6324 fax: 562.923.8370
IDENTITY ‘DUBL-CHEK HI -TEMP REMOVER ‘Blank spaces are not permitted. Non-applicable items or unavailable
(ENT andiet (aero KO-19 Psmalon ton so nd
Section!
WandaaureNer SHERWIN INCORPORATED Eierensy ore Ne aerated. Secor SaoN
a 5530 BORWICK AVENUE Toman phone NO 569.961-6526
SOUTH GATE, CA 90280 aa May 2010
apres Sais
“Section li — Hazardous Ingredients Identity Information
Tazardow Conponers Specie Chemical Nae; ConmonName()___OSHAPEL ——_ AGGIHTLV er as x
Hydrocarbon Propet (iquied petoleum CAS n0.68476.85-7 nonelisted 1000 pm - 2
oes) LP.
Nonionic Surace active agent CCAS no. 68191-4088 none sted none listed e =
Sedum Nite (CAS no. 7632000 ‘nla va : 03
R0, 5-0
NOTE: Spray can package contains a iquitied petroleum gas (similar propane) which is.
‘extremely flammable. Contents of spray can are UNDER PRESSURE. Do not puncture,
incinerate, burn, compact or heat. Exposure to temperatures above 120° F may cause
bursting. Avoid prolonged exposure to sun's rays. STORE UNDER 120°F. Donot place
on heated surfaces. Do not use as a hammer or otherwise misuse. Keep away from
‘sparks, torches, welding areas and open flames. Do not use in confined area or area with
litle air movement. Employ means to prevent vapor buildup. Avoid vapors when
inspecting high temperature surtaces. Inspect in small increments.
‘AVOID VAPORS WHEN INSPECTING HIGH TEMPERATURE SURFACES. INSPECT
IN SMALL INCREMENTS.
Physical/Chemical Characteristics
Gravy =D)
we | Sea =
Vapor Pressure (mm Wa) ating Por
In.cans @ 70°F 50 psig “ nla
Vapor Density (R= 1) Evaporation Rate
not determined wa__| t@ayrroatate= 1) ua)
Seay Water
partial
‘Appearance and Odor
spray can package petroleum odor
Section IV — Fire and Explosion Hazard Data
Fah Poin eto uses) Farmatie Umi Te aL
ot applicable to spray cans propellant portion ter vol_| 9.5% vol
Eainguing Media
wea Meda co, Foam Dry chemical
Spec Fre Fring
Procedures
Spray cans under pressure...explosion hazard exists. Do not enter spray can storage area i fre present.
‘As encountered with, wmablo gas as propeliant
conSiSaRSs Steal Rasa" Ckpteion hazard ons won’ pray Cans ot up.Section V — Reactivity Data
Sabi Unstable Conditions
fo Avoid Open flames. Build up of vapors. High temperatures. Hazards normally associated w!
Sable x ‘aerosols.
Tneompatbiiy (materials fo avoid) Strong oxidizing materials
Hazardous Decomposiion or Byproduct= Carbon monoxide, Carbon dioxide
Hazardous | May Occur Conditions| NA
Palymonzation to Avoid
WitNotOccur | x
Section VI— Health Hazard Data
Rous ofény Eyes? primary nhalaton? NA skin? primary Ingestion? ia
(eete and evene) Breath thesia, headache, di é : Skin contac
Hear sere sic) Breathing of vapors may cause anesthesia, headache, dizziness and upper respiratory itation. Skin contact may cause
Groat ot vapors ey casio Eye contac may case itaion tearing and feaness. Swalowing may cause tation,
wosea, vomit and armed. Aspiration othe lungs may eause proumonhs.
Carckapeniee TPF = TAR RanoRaETAT OBR age
Signe & Symptoms
otBrpocure Eyes: iitation Inhalation: Light headiness. Skin: Moderate ir tation
ee ang
aly Aparato
Speen” Skin contact may aggravate existing dermis.
Tyga: Maediatay Tush ayes w water and continoe washing oral east 15 minules Objain medical atienion wo dela
EneaereysFeet FURS I yneS gr doap and water, Homove ad wash contanetes cating Ingestion: DONO! induce voting, Get
snedicab tention f voting Sccurs epontansously. esp head below his fo prevent aspiration of iqud into lungs
° Porinhalation: Removeto esha ° “ .
Section Vil — Precautions for Safe Handling and Use
‘Stops 19 be taken i
‘material ig rleased With aerosols, spl o consequence uninely. Eliminate all gpen flames and sources of janition n vicinity of spill o
orsileg released vapor. Ventiate area. DO NOT allow vapors to bi ‘Agsorb spills w/ absorbent material. (A tre or vapor
hazard may stil exist as absorbent material will absoro Gnly Iquids, not vapors.)
faste Disposal
Menes Place contaminated materials in disposable containers and dispose of where permitted under Federal, State and Local
regulations. Leaking spray cans should be placed in open pail until pressure has dissipated
Soring & Handling
eit Storage: Store spray cans, in cool ventilated areas away from sources of igriton such as sparks, wold
ee * POY BO NOY Soe move 128k SAS wha re dept Yor Stoangreauomenies es one wows
Other Precautions
Emptied containers rotain vapors and product residues, DO NOT wed, cut o dill container. Retained vapor is explosive
" DBC SPS Fy SPly cars propery: BO NOY mnchorale, cushy compe orbum, P= OO
‘Section Vill — Control Measures
SoateRepnmy Pomcin TOTAL DASHES ata Oe MORN SU a NOS mae
Verdin | E55 Suifciont to koop vapor concentration below TLV. | SP#=! one
ea Traore apoio or a
sieeve Ses Thins OPamial saely T posse spraving
ea a a
Clothing Equipment
WorkHygoric Practoos
z Wash before eating. DO NOT smoke.