Reg. No. : d aS
Question Paper Code : 42377 AY
B.E/B.Tech. DEGREE EXAMINATION, NOVEMBER/DECI :
First Semester
Civil Engineering =
GE 1101 — ENGINEERING GRAI
e (Common to all branches of B.E/B.Tech. e: ineering)
(Regulation 200:
Maximum : 100 marks
S sheet book provided.
‘Time : Three hours
Answer all FIVE questions it
(6x 20= 100) +
1. (a) The top view of a li points a and 6, 10 mm and 50 mm below
the xy line and has points a’ and 6’ 40 mm and 15 mm
above the xy linf(reSpettiyely. Determine the true length and inclinations
of the line wif . Take the distance between the end projectors
Or
of 60 mm diameter is kept 35° inclined to-HP and
ular Yo VP, so that the centre of the lamina is 40 mm in front
the lowest of the circular edge is 15mm above HP. Draw
the lamina.
(b)
2. (qa) \W hexagonal prism of base side 25 mm and height 60 mm rests with one
its rectangular faces on HP. If the axis is inclined at 35° to VP, draw
yrojections.
Or
() A regular pentagonal pyramid has an altitude of 65 mm and base side
30 mm. The pyramid rests with one of its sides of the base on HP such
that the triangular face containing that side is perpendicular to both HP
and VP. Draw its projections.a)
(a)
A cylinder is resting on its base upon HP. It is cut by a plane inclin
at 45° to HP, cutting the axis at a point 15 mm from the topIf tHe
diameter of the cylinder is 45 mm and height is 60mm, draw
projections of the sectioned cylinder and the true shape of section.
Or O°
A right circular ‘cone, 70 mm base and 70 mm height, re én
the ground plane. A section plane perpendicular to VP an 35°
to HP cuts the cone, bisecting its axis. Draw the dev
lateral surface of the cone.
A sphere of 20 mm radius is placed contrally nal slab of
side length 25mm and thickness 20 mm. Dr: ic view of the
combination.
Or
A hexagonal prism of base side 20 m
the ground plane on one of its recta
at 35° to the picture plane. A cory
station point is 60 mm in
bisects the axis. The station
Draw the perspective view ofthe P
a Syfength 50 mm rests on
ee les with its axis inclined
of hea e is touching the PP. The
lies in a central plane that
mm above the ground plane.
Draw freehand the front ip view and side view of the object
necessary dimensions
‘Through hole
2 42377ject sh
(b) Draw freehand the front view, top view and side view of the obj
a
z
sary dim
in Fig. 2. Add by freehand the neces:
42377