Page 6 DIN 1630
Table 7. Summary of the scope of test programme and documents on materials testing
See figure 1 for sampling points and location of test pieces; see subclause 5.3.1 for batch size.
Testing
No. | Type of test
clause
Sub. Scope of test programme
Responsibility
for carrying out
the tests
Type of document
(on materials testing
2 | Impact test
1 | Tensile test
55.1
5.4.1 | 1 sample tube per batch, 1 test piece | By agreement
DIN 50049-3.1.,
or DIN 50049-3.18.
or DIN 50049 -3.1.C
5.5.2 | above (No.1)
pieces)
5.4.2. | At one end of sample tube specified | By agreement
(for wall thickness |
210mm): 1 set of 3 individual test
DIN 50049-3.1.4,
or DIN 50049—3.18
or DIN 60049 -3.1¢
3. | Test on annular
test pieces!)
555 | 1 test piece
5.4.3 | At one end of each rolled section or | By agreement
5.53 | at one end of each subsection, for wall
5.5.4 | thicknesses not exceeding 40mm:
DIN 50049-3.1.4,
or DIN 50049-3.18,
or DIN 50049-3.1¢
4 | Nondestructive
testing of tube
| ends
53.1 |For wall
of 25mm
thicknesses exceeding | Manufacturer
5.5.9. | 40mm, at the tube ends over a length
DIN 50049 -2.12),
5 | Leak tightness test
63.2.1 | All tubes
557
Manufactui
DIN 50049 — 2.12)
6 | Inspection
5.68 | All tubes
| By agreement
DIN 0049-31
testing of tubes
559
of surface or DIN 50049-3.18
or DIN 50049-3.1¢
7. | Check on 5.5.10 | All tubes By agreement | DIN 50049-3.1
dimensions 55.11 | or DIN 500¢9-3.18,
| or DIN 50049-3.1¢
8 | Product analysis) 6.4.4 | By agreement Manufacturer | DIN 60049-3.18
556
9 | Nondestructive | 49 | By agreement Manufacturer | DIN 50049~3.18.
1) See table 8 for information on the dimensional ranges for the application of these tests
2) This certificate may also be included in the next higher stage of document.
3) The product analysis shall only be carried out if so agreed between the manufacturer and purchaser.
Table 8. Tests to be carried out on annular test pieces, asa function of diameter and wall thickness of the tubes
raises Wall thickness, in mm
outside inside <2 2sss16 wei Flattening test | Ring expanding test | Flattening vest |
[> 146» ca : Ring tensile test, Fling tensile west 2)
°) This init shal so apply for tubes ordered by inside diameter, Hf the outside dameter exceeds 14 mmm
tensile test.
2) For tubes with inside diameters not exceeding 100mm, the flattening test shall be carried out instead of the ring