Professional Documents
Culture Documents
Onkyo TXSV313 Rec
Onkyo TXSV313 Rec
Only 230V model
Instruction manual
NMA.3057,AM loop antenna
Connection cord
UM-3,Two bateries
RC-2518,Remote contol transmitter
‘YAE21.0237,FM adaptor
-19-
SSIES
NOTE: :230V model only
2519230
25K365-GR
2Sc1740S-R
Dratiees.
asp i464
branes
ccincurt no.
a0i,b202
Dang.b207
Lio
02
Ls
Laos
List
us
0.202
x101
x102
xsi
xis2
x108
coor
cuoacias
ccus
ca
cy
criserss
case
ciss-cis7
cise
cist
en
cane
ens
cor
e208
cao9.c22s
cane
case
cais.cx6
219.0220
cm
xs
~47-
Penrariane)
PARTNO. DESCRIPTION
Diodes
223205 o 1SS210A oe
mae 188133,
Coils and Transformers
aso NFIF-4072
23402 NPIP-A073
2ssguiMo22 ——NCHASTS
rere) NMC-6070 W/Q>
3010130 SFEOIMZ2A
374726724 4700p 5% 50V,Phasic PIQ>
378728628 S600pF 58% 50V,Pasie
INPT-A111DG
SNSOS1
NSCT-4PD34
NSCT-4P451 Only 240 model
2. Change of FM/AM hand step.
With the exception of the Worldwide model. BAND STEP
0° switeh is not provided
(FM)
AND STEP Rn vst
TWOKH=S04H | Adon Open
SOkH/ “IOOKHY | Ebminated | Shoe
(amy
BAND STEP RD m8
Jy R72} and R722 Carhon resistor OKO
(Part Nos 17341044) are wed,
= Worldwide model —
Worldwide models are equipped with a step band selector
This switch is located on the back panel. This
switch iS se SOKH/CEM and 9KHZAMIat the factory.
but may have to be reset 10 10OKHZ and !OKHy depending
tom the area where the unit is used
De-emphasis FMstep — AMstep
Europe: 50 psec SOkHz — 9kHz
USA. 75 usec 200kHz © -10kHz
DISPLAY CIRCUIT PC BOARD
SELECTOR AND POWER ANPURER PC BOARD
3. Memory preservation
This unit does not require memory preservation batteries.
A builtin memory power backup system preserves
contents of the memory during power failures and even
when the unit is unplugged. The unit must be plugged in
and the power switch turned on and off once in order to
charge the back-up system. Note that since this is not @
permanent memory the power switch must be tumed on
and off a few times each month to keep the back-up
system operative, The period of time during which
memory contents are preserved after power has last been
turned off varies depending on climate and placement of
the unit, On the average, memory contents are protected
over a period of 3 to 4 weeks (a minimum of 2 weeks) after
the last time power has been turned off. This period is
shorter when the unit is exposed to very high humidity or
used in an area with an extremely humid climate
4. Safety-check out
(Only US.A. model)
After correcting the original service problem perform
the following safety check before releasing the set to the
customer.
Connect the insulating-resistance tester between the plug of
power supply cord and terminal GND on the back panel.
Specifications: 3.3 Mohm +10% at SOOV.
5. Change of voltage
Worldwide models are equipped with a voltage selector to
conform with local power supplies. This switch is located
fon the back panel, Be sure to set this switch to match the
voltage of the power supply in your area before turning the
power switch on,
This switch is set to 220V at the factory. Voltage is
changed by sliding the groove in the switch with the serew.
Ariver to the right or left. Confirm that the switch has been
moved all the way to the right or left before turning the
power switch on,EXPLODED VIEW‘daidio34s WIEWAN wa HLM KINO BOVIUTE
SOOHS PUIG ANY ULI 40 NSH! YOs TWILL
SUV Y NAVIN Af GAISLLNIAE SLNINGJNOD SHA,
“LON
quo [290 Xa =
Aquo pou AdET =
pout Spinto
[uo PpOW ADEE =
uo POW ADE
su
vevosvent
riogrertt ha
wou Ans omnyeal-o9rSaVN. cong
tp Ksse po 2
yo Alo NO DORM SAVN OL ORSHCH
<> Aas 0
Flos ONO M-OBO AVN BL-OBSHERHL
i> Asse pao
wos fds sanevL-o9r SVN V-ODEREEHL
ca> se pmo
SOMA -AOSAYN LORE oa
eyy> os |
Mya Dunya GsoRIANN — lassrCeH
a> sep
in
oa
nousiossa—-oNsuS
‘on 3
Assepmog ad
ouDaunon PE Gtoa'VL-9SraWWN— VTOSSRCPRE
a> Aorpa90 x
iu aumoN PEE AQUET-ISUAVWN LSE
<> os ag
xine Sus ULsS9ESIYN — MLSSSECIHE
Ase puto,
shun AMSVLSSORSIGWN —_VESSSHCHEIT
a> sn tog
iso Sauber -s99rSIaYN UE SsseCHET
veteseestt
vsswnure
Avro
sweeoce
oeiseuee
ost soreure
OINOMSEOIYSE
‘ONODAHOIVSE
oss sys 48'0-ND
ANON H9eROSe
CANOAYWRROSE
<> 11 VLOLIIIN
neseuce
soasose
outtse
Arcitse
> xco16se
srOOSE
‘ineszuse
suorse
‘sos
Nouswossa
“onsuva
050.050
80'5050)
‘tnt Z068
ost
rove
sow
061
sd
sts
ws
naa
sovoraudlersoe"owaseSLis sore
sada, AvagHRi¥e
pen oes ANKUILLLZ
fn I OWINGDAIE RFC
sabe pewursTOWASIRGE ———SlOGPICR
ans Bild OS MRrALLLE ——-SRWELLER
sonny
scat
PSiowawrSLLC ——yalOcrsEW
sp ode
suse omurisias MrsWSE aw
SMOHSCL-STON w
wv
osunnetz Ww
soutrie ow
ss0euz sv
honoree wv
vos w
seemed
<> patie
ds
sap puedsey
ep pind a w
DAW W
nouaosza ONAN “ON 43H
ASIT SLYVdMICROPROCESSOR DESCRIPTIONS
te
TEER ntTerminal Description
Pin No, [Symiboi [Description
1
2 [sczment and key scan ouput terial
3 1H when active
ase
s|POFF Hiss the input ermial for deistion ofthe Noppage of elecie
ferent. "L* when the stoppage of elec curent
[BANDA |tniitizing inp terminal for epion setng of FM band
7 [BAN
‘5 [ast 10% [aia ap ternal or eon song of AM and
9” |SvS IN [System cade inp terminal" when active
10 Jerorecr —[Proection cient operation desction input teminal “HP when ative
nfs [Broadcas detection input rina" when ative.
Contra the top of ato tuning and output TU MUT(A37)
12 [STEREO |store broadcast detection input terminal
when sero oaks _
13 [POWER [Power comol ouput teminal "W wen te power ams on
1 [e Not se _
13 [en [connoct he termina EN of he xendsd IC a PDSIESC(QSST
16 LAT, [Connect th terminal LAT ofthe extended IC ys PDG3SC.
17 [PHONO |Nou se
ws [ste |SELECTIVE TONE control out terminal
1H" when this switch ts
[REN JRF ese inp termina
RIN [RF MODE
L Loca.
iu [bx
30 [LEVEL |Sipnat level inp control ouput ermal The sgl lvls
puted wo temialsK0K3 when his ternal i the high ve
a (ko key scan input terminals won pia 20s ow."H" when alive,
Signal level inp esminal when pin 20s igh,
me
ky inp of [Signal evel
a ik [none LeveL
KO. LeveL
KO.KLK? (LEVEL
IKO.KI.K2.3 [LEVEL!
alae [Cannes othe trina CE of PLL ICM I001 QUOT,
sitches(Q302.Q601 serminal SECK of digi delay
9551) and crinal CLK of lei volume (451)
27 [DATA [Connect othe eminal DATA of PLL ICyenminal DF oF analogue
‘witches serminal SEDATA of digital delay semiaal SIN of
lexcned IC and erminal CLK of electro volume,
EM band sewing
BaNDI| saNDO| Rope | Feguensy Range | Cannel Sas]
[oo To [usa | srssoentis oot
0 Eszpe | a7 sOsiok oom | sate
1] 0 | Wowwide| 7 0-08 contr | sos
1 LTE tpn Teo on ose
AM band sewing
[usa | sso.ncuie oat
0 Wengwise | 31.152. ntiPin No. [Symbor [Description —
28 [FUNC [Connect o he terminal CE of analogue swithes und terminal
CE of cco volume,
29 _|LED No se.
20 Ix [ceramic escilnor connection ecminal for main system clock,
axa |comect othe 419M ceric ocilitor
s2_|vss [Ground erin
a3 fxr [Ceramic oxiitr connection terminal for sub tem clock
33 fxr No sed.
35 [MA MOT [Audio mating ost onminl when ge loco cng ie
36_|SIM MUT_ [Nov used
27 [Tu MUT [Tuner muting ouput ierinal"W™ when asive
38 [REQIMODE [Connect ose terminal REQ of digit deta
39 [Reser |Reset input eminal,"L when active
40 [a1
a1_|or
2 io |
3 [on
os bi outpet terminals" when active
sles
465_|or
47 lox,
48 loo]
solo
Si_|so
sz__|se
33 sp Segment output terminals"H" when active.
Sasa
5 [sm Z
[56 |VLOAD Pulldown resistor connection terminal of FIP conalledriver
S_|VPRE [Powersupply erin! of ouput bul of FIP conuollrdeiver
Isc
si
Ise {Segment and key scan output emia
or [se SW when active
sr
6s [vp [Powersupply erin (65) 7
By 3 | n 2
a] s) seer MAIN SPEAKER| POWER
31 se | petav rive [pouay | center MooE:
2 [se] tare2 | taper | vpsos | vipeo
[ss] op. PHONO aM FAL
fs 8 z é s
wo | sy | ciassscan | DTUNING a %
sls [ w DOWN | MEMORY | MUTEMODE
sel se [ cass [aasse | case | Cassa
ssl se cuasst | cassie‘TX-SV313PRO|
IC BLOCK DIAGRAMS AND DESCRIPTIONS
toa
LA1266 (FM IF and AM Radio System)
imi I Cy
[JH
}{sitfa}—-9*
e201 ae ate 2 .
‘AN7470 (FM Stereo Decoder)
fl tl fm)
l
A
Jp
eta ee
t T Pp Tite)
L_ Le
Deo eo oe oD
0251
BA7625 (Video Selector Switch)
= mln p=]—a aaa
our Te. figjin 1 ‘AL 8 Le [wommoxour] [Ceo fe voor
fe ct pe peti tpt
ono figjer. a wpe pe} ie] a
tf | eT
r
ws (I fav our 1 hihi The a oe
bhi ins ioe bic ins
sno = vee
wa BHP lias biel 2 4 {a |e [voura
Ell
cmt Bh Pry {ijert e wht
wf fe [ine
ws [iv our 2 re
ctt ofa fi ayer ¢a107
LM7001 (PLL Synthesizer and Controller)
& Bete 8
Ty Eisaeeme
nh *
#) ce
ae “gk
& dons ae ar as
Pin No. | Terminal Description
1 xOur Connect to the 7.2MHz crystal resonator.
2 [XIN
3 [ce Chip nae rial, Cones othe PLL eminal of nlsoprocavor
+ [a Ser lok ip terminal: Connect othe CLOCK eminal of miopoceon
5__| DATA Seal aa np rminal Cones tthe DATA erin of meoproceson.
6 _[sNY Roxie
7__ | AUTOIMONO | AUTOMONO session ouput eminal."L" whes AUTO.
= [Rr FM band conto up terminal °L” when FM
9 [ant ZAM bare con opt erin when AME
io “AM oes silo pat eal
u i oa seit eal
2 Power soppy rial or tack
13 ~_| Power supply terminal. _
7 ‘Charge pump ouput ofthe phase Steir whieh constites the PLL, Fgh eas outpuied wha
the vided oc oscilator frequency i hgh than he reference fequeny.
ofa Te hepsi case, low lew snp Flag aor when the fequencies matched
‘he opti applied othe vrai eapaitor diode inthe local silat through te low pass
fies
is [ve Ground emia
=10-Q302
LC7822N (Analogue switch)
® a /-
a
oo Ry] t—B—] ow
+i 4
Re
os LB , ——
°C
“ST
mv Clever sine
—_t
an
aan
ean
“et amrr nearer] om
—_ I
Q302
Pane. Tene Dessnpion Pin No a [beccrpion
a vest
: a
7 a
-n-pe EET G)
Q706
BAG125 (Signal meter driver)
ouT
Q541, Q571,Q572
$1-18751 (Power amplifier)
oncom
BT
fis! 4H SUE |
alae
aT,
ARLE
12+Q691
LC7823N (Analogue switch)
ou bog cB mo
ocap
oo +5 cet man
vol wos os
ow Lge ca
oof Te
tna] rte
1) } vo (9)
691
tee ae ast nie be [et a
~13-rere)
451
C7536 (Electro Volume)
g BB 2 2
a 2 $ 3 8
bit Tewere
en we cs
0 ee is
ne one |
No, TERMINAL, [DESCRIPTION Na [TERMINAL [DESCRIPTION
1 JL SaB IN [Sd step atenunor np rina wc. Serial data input eminal
3 [LCT [Ferminl for loudness i [Dr Serial data input terminal
[Cra —— [Terminal for loudest 12 [ce Serial dae input emia
5] 5a OUT [S48 sep anenuatr ouipareminal 21 [VCC [Power soppy terminal
6 [L1dB 1 [lob sp aenoator ng terminal 22 [RVM [Common terminal of volume
§[L1dB OUT [148 sep atenvator oupot terminal 23 [1a OUT [168 step aerator ouput terminal
97[LVM [Common eminal_ of volune 25 [R148 IN_ [108 sep atenastor input enna
0 |VEE Powersupply terminal 25 [8 545 OUT [508 sep anemusor ouput ernnal
mag Select terminal of address ae drag dat format! 27 [R CT? [Terminal fr loudness
13, ]VDD [Powersupply termina 28-[R CTI [Terminal for loess
1 [58 [Powersupply erin 30 R54 TN [5B step atenusior inp trial
Q501, Q502
#PC1298V (Power Amplifier Driver)
-14-NJM2177L (Dolby Pro Logic Decoder)
TET ETT joel | ce | Tobe EEE
TTT
[snr ar —, 99 cee,
ss a}
tera) setters
a661 .
M50198P (Digital Delay)
Aa A A Ae eA
+ F T eros tw
ES] art |
att oe ast a
Fass | Syatet —[Funaion =
[1 [DIG GND — [Powe spay srmmalof aia scion
2 [056.19 — [Cone ie 327M ceime sila eal Gack
BEISEDATA [Tera DEL res eyo Teri SEDATA wane pe
5
7} DeLA [flv rode col ria
5 | Cowen
[Cio [aac r
Ti] biG ond — ogi pve
13 EPR OUT [Cont he secondary ow pus kr basen pes BET
ce
[Tis] 0er our opens pier suprimia
~18-
| cei 7
1] REF —
m_| _onin
p [aw
24 | TANG WCE [Power soppy ronal of rao tonA)
Q7o1
11-BT-107GK (Fluorescent Indicator Tube)
106. 9G
fac) Or] i] roco | od Zia i
i j'
bit J i ‘id |
1G
fens wo. af s[e[slole[s[a]ole[alo 35] 36] 93 [52 [a1 [a0 [29 [os | or Pa.
fconnecrion [rz rz [ive [rr | fre [ro | ref sf ber mw af e wo wo [| Pn
Jowwo [as fae as | a2 far] ao} w fe] sf as | oe ote atatati
[cowsecion [we [ye Lye [we [yr [ne [wc] nel wclne] ualiecl 96 [1a] 16 Poa [so [a0 wel we bere}
iG 10G 96 sc [76 sc] 4c [3c [ac |ic
PI aB AUDIO MUTING | TAPE-2 MONITOR, d{/djdj]djdjajad}a
2 cH REMOTE 2 clelele[elelec]le
P3. mSEC MAIN 1 bib] bi bi] bi bl] bib
Pa Mint SPEAKERS [VIDEO afatalalalalala
p5_| muntisource | canrsror |surrounpmope | e[elelelelelel|e
P6 Frame of CD. FM MUTE. DOLBY flri fie fl rp ri se
1_| Frame ot PHONO on HALL zlels zlelele|
Ps _| Frame of TUNER. OFF seuecriveTone [bh] h[h|[n|n| nl n|h
po _| Frame of TAPE? STEREO sourcepmectr | jl ilililililili
P10 | Frame of TAPED 3 MEMORY kfete[e [xk] [kT
Pit | Frame of VIDEO? BI SLEEP m{m/m|[m[m|m[m[m
P12 | Frame of VIDEOL 52 St al{a{nto[n[n]n
13 | Frame of SOURCE 33 ‘Auageiiay plelplplelplrl>
pit | __RECOUT Ba Marz) e[r[e[r[r[e[r[r
PIS; 33 -[olololo[-|-[-
=16-Ea
Q703
PD17103CX-531 (Remote Control! Decoder)
Renoe ro
Teansminer | ZA7 | control ey Remote | O71 —
Infrared | GPIUSTIX Secoder Line
osc: OO N 7 xp
vos: <— SANDY
vos! <— HGF
“REMOTE IN —>PODO POB) <— VOLIND
PHSENS —> Pop) POC} <— VOLUP
roc? <— VOLDOWN
svsin- —> pops pocl<— PLAYER
yop
BEE EEE
G
gy
y
POWER —>Pon? [|
GI
a
Poco <— SYSouT
{Bin We [Symbor | ——Terminar Description
FV Toscr [08 Connest tothe BIMHE ceamieossliator
Tosa _
3_[RES | RESET [System reset terminal, Active low
[DST [Pope REMOTETR [Sigel inp trina! fom preamp forme Son
S77 [PODI [PHONO SENES | Phono detecion mp terminal Adie ww
6 |POD?_| POWER Standby detetion input terminal. During low ioput_ only he POWER coor
(a TPons_ [sys in Sytem code input fermi
(ee 8 Power supply Terminal:
7
i IN, data code (Bits, andthe serial code (12bts) that has been converted corresponding (0
the decoded data code (bits)
i {pOci PLAYER player PLAVREEJECT s Input. a Nigh pulse of 200m f output
Th] PGC) | VOL OWN] When the valome DOWN code i input. 2 high pulse of 130me i outpat
POCO oT ‘Output at this terminal are the custom code (Iébis) remote control code input to REMOTE,
i [POC}| VOL UP [When the volume UP code is input. a high pulse of 120m is output
[7 prose” | vorIne Durng the output of VOLUME UPIDOWN. a pulse ( JTLI1 TLE 0m) i output
l (ot used.)
ry | POBI | RECEIVE This is the display output for remote "en decoded code is
1S__|POB]_| STAND-BY | STAND-BY indicauon erminal
1 1Vy | GND. [Ground terminal
aeESET)
Q705, Q851
uPD6345C (Extended IC)
EN
TAT
so
OF
o7
OT
Pino. Symbol] Deserpion
Vv es a
> [eX ‘Chip enable inp iermial. Connect wo the erminal EN of
the microprocessor
3 PEAT eaten inp ermina. Connect emninal LAT oF he
SCK ucroeacessoe
7s Serial da op rina Nowe
SIN
+ 240V model only
‘NOTE THE COMPONENTS IDENTIFIED BY WARK Al]
IRE CRIFICAT FOR KISH OF IRE AND ELECTadC
SHOCK REPLACE ONLY Win PART NUMBERTX-SV313PRO
8
7
a
a
Ge
Ease) |
NOWOAS YaI4IT1dWY
Wvudvid 49018
ag—71300W Aozt —
NOLLOSS YSNNL— ST300W Y3HLO—