4.3.4.5 Adjusting the Sensor Intensity
Go throng the following steps when installing the Sinisher or placing spe
cif sensor,
SF essere ost mache in sen
ee LE
reste {I}
@
5) Se the DIP etch SW382 [1] ofthe sitch BCB as shown (1: ON), and
| ‘preset enter baton (SW38D) [2] to stat sensor neay adjusts
3) nse secediver [2] thouh debe] th brio face of the ty: "
thea, deeusnge the arin the direction of] a lower the sy A ta
‘he diechon of 8)
ie)
‘OSPaBT
sama A
‘Seer
(eae
Gee o
i
7 I yf ser fy Ge the LED fais YD, en the 2
(Gow Se4) (1) 3E3) 2} Baton ts id out he coe amber eed
‘the FED [3 and eplnce the oly Sensor
eew)tll
No Sensor
1 UNS offer Path 1
2 UNA Buffer Path 2
3 UN24 Lower Path
4 UNI2 Horizontal Sensor
5 Puich Chip Case Full Sensor
6 UNIS Middle Led
7 UNIG Top Led » Top Tray
8 UNIG Bottom Led.
9 UNIS Middle Led
A UNIS Top Led :
b UNIs Bottom ns) Lower Tray
") Desach te iside cover (owe) aad he sitch cove}
‘eerew (2)