Generali
zed Computer-Aided Discrete Time
Domain Modeling and Analysis of
DC-DC Converters
F.C, Lee, R.P. Invens,
Y. Yu, and J.E. Triner
Absreci—A geaerazed Sscrte time-domain modeling and salysis
technique & presented for all types of switching regulators wing any
type of daty-eycle contoller and operating in bath contnvoas and
29 2)
such thatthe lighter the load the better the audicsusceptbility,
curee “b” and curve “c.” Comparing these three curves also
shows a significant difference in the magnitude of audiosus
‘ceptiility between Mode-1 and Mode-2, especially when the
frequency of the audio noise is approaching one-half of the
switching frequency. The sharp resouance-ike rise in the fre-
‘quency response at half ofthe switching frequency only exists,
with continuous current operation. This is expected since it
reflects the closetloop eigenvalues at -0.95 for Mode 1, see
Fig. 14, and at the origin for Mode 2. An eigenvalue located
at ~1.0 means an undamped resonance at half the switching
frequency; 25 the eigenvalue moves into the citcle, damping in-
creases; as it moves out of the circle, exponential build-up
and thus instability results.
IV. Coneuusion
‘A computer-aided discrete time-domain madeling and
analysis technique has been presented which is applicable to
all types of switching regulators using any types of duty-cycle
controiters and operating with continuous ax well as discon-
‘tinuous inductor current, Statespace techniques are em-
ployed to characterize converters exactly by the nonlinear
ixcrete time-domain equations in vector forms. Newton's
iteration method is employed to solve for the exact equi-
rium state of the converter, The system is then linearized
about its equilibrium state to arrive at a linear discrete time
model, The stability nature and transient responses are
Studied by examining the eigenvalues of the linear system.
Changes in eigenvalues due to system parameter changes can
be plotted in the complex z plane yielling an excelent design
tool very similar to conventional root locus plots. The analysis
fs alo extended to determining the frequency-related per
formance characteristics such a5 the cloted-loop input-to-
output transfer function used to determine the auidosus-
cepuibility of the converter. The modeling and analysis
approach makes extensive ust of the digital computer as an
analytical tool, replacing highly complex and tedious analyses,
by numerical method and making automation in power con-
verter design and anilysis posible.
Followed by a generalized analysis procedure, two specific
‘examples ate presented to demonstrate the application of such
‘a analysis scheme, one for a boost converter operating with
constant frequency and discontinuous cuneent, the other for
2 constant frequency buck converter operating with both con-
tinuous current and discontinuous current. A composite com
putter program is developed for the buck converter to include
both current modes of operations, During the transition be-
‘tween the continuous current operation and the discontinuous,
current operation, an interesting jump phenomenon is ob-
served by plotting the system eigenvalues on the 2 plane.
‘The jump of the system eigenvalues not only causes abrupt
changes of the performance characteristics of the converter
Dut also, under certain operating condition, of the stability,
nature from an unstable system to @ stable one or vice verss.
‘The analysis reveals certain high‘requency oscillation phe-
nomena at the subharmonic of the switching frequency, an
unstable operation normally associated with constant fre-
‘quency, continuous current mode with a duty-cycle rato
greater than 50 percent. Such a high-frequency’ instability
Phenomenon may not kkely be exposed through other means
of analysis.
{In addition to its partictlar utility at analyzing high-re-
quency controloop-ated phenomena, the analysis also
serves as a useful design tool which provides design guidelines,
for suck important control parameters as the dedoop gxin,
the acloop gain, and the R-C compensation network of a two-
oop converter to optimize its transient response and ¢o star
bile the system.
APPENDIX
[ENTRIES FOR MATRICES FT AND Gi
‘The matrices Fi and Gi for f= 1,2,3,4 are 4X 4. Define
Fé= {fig} and Fi= {gi;g}. The following entries of the re-
spective matrices were derived assuming negligible loading of
‘the feedback loops to the converter power stage:
i =-f0
a rr
1k 1
=e aegh
TGR Ret | GR
Maye Rb (- Rd
Ret RGR Ry OR,
aR ,
Naam Gp wae MIN,
33slat 1
Bue
eae Cika
rea
Pe TRe+R)
Pyrhin
Pn=Refin fss*flss
Ry
Pastas El a
Pan" flan * RePar
Pas*flyy Pa *8ln fuels
Purley Pearzler Peat
Battin Buefin Pas S laa
Bai tfla Fas *Dras Baz > Fla2-
REFERENCES
U1) ¥.¥u,4.J. Bies, A.D, Schoenfeld, and V.R. Lalli, “The applica:
‘on of Standardized contol and interface ercuits of three de 19
{2 power converters,” in JEEE Power Blevtonics Specials:
Conf. Rec, pp. 237-248, June 1973.
(2) G.'W. Wester and R. D. Middlebrook, “Lowsrequency charac
‘wrnation of ywiched de-de converter," IEEE Trent. Aeron.
Erecron. Syst, ol. AES, pp, 376-385, May 1973.
3] A. Cape, J. G. Ferrante, and R. Prajowx, “State variable suability
‘salve of maaltloop PWM controlled de/de regulators i light
4)
ts)
(6)
nm
e
0)
19)
my
22)
13)
and heavy mode,” in JEEE Power Electronic Specialists Conf
ee..9p. 91-103. June 1975.
1M. H. Babaa, 7-G. Wilton, and Y. Yo, “Analytic solutions of
limit eyees i's feedback regulated converter system with hy
teres,” EEE Trans. Ausomat. Contr. vel A 526531,
(Oct. 1368.
FC. Lee, V. Yu, and J. E. Triner, “Modeling of stitching epu-
lator power sages with and without zero inductos-current dwell
tune," in IEEE Power Elecironict Specials Conf. Ret, PP.
52-72, June 1976.
B.A. Owen, A. Cape, and J. G. Ferrante, “Simulation and
analysis metioas for sampled’ power electric synemt,” in
IEEE Power Electronics Specialists Conf. Rec. pp. 45-55,
June 1976.
RD. Midtiebrock and S. Cuk, “A general uniied approach to
modeling switching-converter power states” in JEEE Power
tectonics Specialtts Conf. Rec., pp; 18-34, June 197
RP. wens, V. Yu,and JE. Tanet,"“Time domate modeling and
‘abil’ amas ofan intepal puke frequency modulated de to
fe power converter,” in IEEE Power Electronics Specials
Conf. Rez. pp. 80-90 June 1975.
D.Y. Chea, H. A. Owen, Jt, and T. G. Wilson, “Computer-
aided’ design and graphics applied 10 the study of inductor.
nemy-storape devo-de electronic Powe? converter,” IEEE
Trans. Aerorp. Electron, Sys. vol. NESS, vo. 4, Pp. 585-587,
July 1975,
“Development of a sandard control module for de-de con-
verters," RASA Contract Rep., NAS3-I2948, to be published fn
why, 1977: prepared by TRW Systems for NASA Lewis Re-
szatch Conte.
‘B.C. Kuo, Analyt end Synchess of Sempled-Dese Control Sys
tena. NY: Prentice, ch 4.
RP. Iwens, F.C. Lee, and J. E. Trinr, “Discrete time domain
‘modeling and anasis of dode converters with continuous and
‘Aicontinuous inductor current,” in Seeond IFAC Symp. of Con-
tral in Power Electronics and Blecrical Drives, roc. Dusseldor!,
‘West Germany, Oct. 1977.
rg, Ata dst of ple modulated do- rover
°” IEEE Trans, fad. Elect. Cont. Ins, vo. 12CI-
Beipp. 104-116, May 1975