Brick Entrance: 11' x 3.5' 6 (correction) Staircase: 9' x 5' Concrete Path: 16' x 4.5'
Procedure to create a raised bed
FileName: Raisedbed_201x_8x_username Save to H: drive 1. Start a new sketchUp file 2. Start from origin 3. Rectangle 10', 2' 4. Push/Pull upward 10" 5. Offset top surface inward 1" 6. Push/Pull downward 9" 7. Add dimensions for height, width, length, depth and thickness of raised-bed 8. Triple click to select raised bed 9. Right click and select create component 10. Component Name: 10'x2' raised-bed 11. Paint raised-bed by choosing Materials > Woods
PVC Supports 1. 2. 3.
4. 5. 6. 7. 8. 9.
10.
Open your file: Raisedbed_201x_8x_username
Make sure your raised-bed is created as a component Use the Tape Measure tool to create 3 guide points at 3 inside corners of the raised-beds, 5" down (z-direction, blue axis), 0.5" away from inner surface of raised-bed (x-direction (red), y-direction (green)) Use the Arc tool to create an arc connecting 2 guide points of the width side, make the Arc 1' tall Use the Move tool to move the arc out of the raised-bed Use the Circle tool to create a circle surface, center point at one endpoint of the arc, 0.25" radius, and must be perpendicular to the arc Use the Select tool to select the arc (path), activate the Follow Me tool, click on the circle surface to create the PVC support. Use the Select tool, triple-click on the PVC support, right-click, select Make Component to make the PVC Support component Use the Move tool to move the PVC support to one of the guide point. The position you click on the PVC support should be the point you want to snap to the guide point. Use the Move tool to create 8 copies of the PVC support between two guide points along the length of the raised-bed (see Move Tool: Creating multiple copies (linear arrays)