Load Cell is a transducer which is made to measure load that is
given to it. This research uses extended octagonal ring transducer because its ability to measure three kinds of loads. It can measure horizontal load, vertical load and moment. This purpose of this research is to find critical ares on load cell model which is caused by bending moment and to compare experimental results to Inventor simulation results. The reseacrh uses fotoelasticity method. The fotoelasticity method produces isocromatic line on load cell model which is loaded. The loadcell model was made from Araldite B. The model was subjected to 1kg and 2kg of loads both horizontally and vertically. The horizontal loads were placed 9cm, 10cm, 11cm, 12cm, 13cm, 14cm from support point. The vertical loads were placed 7cm, 8cm, 9cm, 10cm, 11cm, 12cm. The results of the experiment show critical area which appeared around the load cells hole. The comparation shows
that the fotoelasticity method is accurate
because it produces identical result with Inventor simulation