Professional Documents
Culture Documents
ITS World Congress Tokyo 2013 - MSTP 3500 OSN
ITS World Congress Tokyo 2013 - MSTP 3500 OSN
Main Features
Multi-service Provisioning
To meet various service interface requirements in metro networks, MSTP products provide access for various
services to simplify the transport network. Based on a single platform, the new-generation MSTP products
support a broad range of services:
SDH services: STM-1(e/o), STM-4, STM-16,
STM-64
PDH services: E1/T1, E3/T3, E4
N*64K services: V.35, Frame E1
Ethernet services: Fast Ethernet, Gigabit
Ethernet, and 10 Gigabit Ethernet
Intelligent Feature
New-generation MSTP products support distributed ASON features with high reliability, easy maintenance, and
excellent interoperability with legacy networks:
Universal
Switch
STM-N
Converged Architecture
One device
Ethernet
EOD
GE
10GE
STM4
FE
10GE
MSTP+
EOD
10GE
GE
EOS
STM4
STM4
Intra-Device Bridge
Packet Device
SDH Device
10GE
GE
STM -4
E1
10GE
FE
Specifications
System Features
Subrack dimensions
Switching capacity
Packet: 60 Gbit/s
TDM: 20 Gbit/s (high order), 5 Gbit/s (low order)
Service slots
Supported interfaces
Packet transport
interfaces
E1, FE/GE/10GE
MSTP interfaces
Power Supply
Installation
Weight
System Features
Typical Configuration Power
Operation Environment
52W
Long term:
Short term:
Temperature
0OC to 45OC
O
Relative Humidity
-5 C to 55 C
10% to 90%
5% to 95%
ATM/IMA PWE3
ETH PWE3
IGMP SNOOPING V2
Blacklist
Broadcast packet suppression
ACL
DiffServ mode based on traffic classification
Simple traffic classification, complex traffic classification, per hop
behavior (PHB), and ACL
Committed access rate (CAR)
QoS features
Hardware-based OAM
ETH-CC (continuity check), ETH-loopback,
Ethernet OAM
ETH-link trace
Remote loopback, remote fault detection
ATM OAM
RMON (RFC 2819)
LM, DM
MAC/PHY loopback
1:1 protection for label switched path (LSP) and pseudo-wire (PW),
guaranteeing 50 ms switching time
Multi-section pseudo-wire (MS-PW)
Carrier-class protection
Clock synchronization
MSTP Features
Interface
Carrier-class protection
2-fiber MS-SP Ring; 1+1, 1:n (n<=14) Linear MSP; SNCP; Fiber shared
virtual path protection; DNI (ITU-T G.842)
Ethernet Service Protection
RSTP, LAG
Two external clock inputs/outputs (2 MHz or 2 Mbit/s)
Clock synchronization
System Features
Subrack dimensions
Switching capacity
Packet: 100 Gbit/s. TDM: 200 Gbit/s (high order), 20 Gbit/s (low order)
Service slots
System Features
1+1 hot backup for power supply modules
Highly reliable design
MSTP INTERFACES
Supported interfaces
WDM INTERFACES
Operation Environment
Long term:
Short term:
Relative Humidity
0 C to 45 C
O
-5 C to 55 C
10% to 90%
5% to 95%
ETH PWE3
IGMP SNOOPING V2
Blacklist
Broadcast packet suppression
ACL
MPLS OAM
Hardware-based OAM
Ethernet OAM
ETH-link trace
10
Clock synchronization
MSTP Features
Electrical interfaces: DDN (V.35/V.24/X.21/RS-449/RS-530/RS-530A),
E1/T1, E3/T3, E4, STM-1(E), 10/100BASE-TX, 1000BASE-T
Optical interfaces:
Interface
11
MSTP Features
Mesh Protection and restoration (ASON)
-Distributed restorable rerouting protection
-Five dedicated protection scheme levels based on different SLA:
Diamond, Gold, Silver, Copper and Iron
SDH Network Protection
2/4 fiber MS-SP Ring, 1+1 or 1:n (n<=14) linear MSP, SNCP/SNCMP/
Carrier-class protection
SNCTP;, fiber shared virtual path protection, fiber shared MS-SP Ring
(one optical interface can support 2 groups of MS-SP Rings), DNI (ITU-T
G.842)
Service Protection
Ethernet: RPR, ERPS, RSTP, LAG/DLAG/PPS/BPS
ATM: VP-RING, PPS/BPS
Electrical Interface Protection
1:n tributary protection for E1/T1, E3/T3, E4, STM-1(e), and FE
12
MSTP Features
Ethernet Over SDH
- GFP/LAPS/VCAT/LCAS
- L2 switch, 64 aggregation directions for powerful Ethernet
convergence
- Mapping granularity, VC-12-nv/VC-3-nv, and VC-4-nv
- Point-to-point LPT, point-to-multi-point LPT
- MPLS and stackable VLAN for L2 VPN
- 4/8-level CoS, CAR based on 64K granularity
- IEEE 802.3ah, 802.1ag
RPR
Multi-service Transport Features
Clock synchronization
13