Professional Documents
Culture Documents
Multiple Choice Questions
Multiple Choice Questions
Noise
a)
b)
c)
4.
5.
TO
6.
If CMRR is high ,the wide variation of input within the tolerable
limits of the
equipment makes output
j) high
k) low
l) the same
7.
8.
9.
10.
11.
12.
If input frequency is exceed the slew rate the output will
be________.
a)
distorted
b)
not distorted
c)
amplified
13.
14.
Open
_________.
a)
b)
c)
15.
16.
The
a)
b)
c)
17.
Operational amplifier offset voltage due to input bias circuit can be
significantly
reduced if we use
a)
b)
18.
The standard supply voltage for an ordinary operational amplifier is
_________
a) 15 volts
b) 13 volts
c) 12 volts
19.
22.
23.
24.
25.
26.
27.
28.
instrumentation amplifier is used to amplify the output of
__________.
a)
speaker
b)
transducer
29.
30.
31.
In which of the following is an operational amplifier (op-amp)
used?
a)
b)
c)
d)
oscillators
filters
instrumentation circuits
all of the above
32.
What is the difference output voltage of any signals applied to
the input terminals?
a)
b)
c)
d)
33. What is the difference voltage if the inputs are an ideal inphase signal?
a)
b)
c)
d)
signal
34. The larger the value of CMRR, the closer the output voltage is
to the difference input times the
difference gain with the common-mode signal being
rejected
a)
True
b)
False
35. What is the voltage gain of the unity follower?
a) 0
b) 1
c) 1
d) infinity
36. What is the scale multiplier (factor) of a basic integrator?
a)
R/C
b)
C/R
c)
RC
d)
1/RC
39.
OBJECTIVE QUESTIONS
1. What are the Four types of differential amplifiers ?
2. What is the figure of merit of a differential amplifier?
3. What is the swamping resistor in differential amplifier?
4. The transfer curve of opamp is the graph of ________
versus differential input voltage.
5. Input impedance of DIBO-DA is________.
6). The gain reduces in case of ________ feedback.
7)The distortion increases in case of _______ feedback.
8. The specified value for slew rate of 741 opamp is ______.
9) The specified value for open loop gain of 741 opamp is
______.
10)The level translator is to shift _______ level down to
ground.
11)For emitter coupled amplifier RE-> , CMRR-> ----12)The second state of OP_AMP consists of dual input ------- output
differential amplifier.
13)Differntial amplifier is ----------coupled amplifier
As common mode gain decreases the value of CMRR ------------14)Current source is used as ----------element in amplifier
15)Biasing circuit provides ----------stabilization
16)Level shifter of op-amp should have ----------input impedance
17)Differntial amplifier is perfectly balanced if transistors are ----------18)Level shifter of op-amp shifts o/p dc level down to -----------19)CMRR is -----------proportional to RE
20)Offset voltage compensating network is connected in between pin
number ----&----- of OPAMP
21)Output stage of opamp provides ------ o/p resistance
22)1DC voltage is well above the ground potential due to ------coupling.
23)To overcome noise problem in level shifter ------- is used
100) What is the major difference between Analog & digital PLL?
101)List the applications of PLL?
102)What are the two basic modes of operation of IC 555?
103)List important features of IC 555?
104) What is a Regulator? List four different types of Regulators?
105)What is Switching Regulators?
SUBJECTIVE QUESTIONS :
114)An amplifier system has the following input and output signals
a)
b)
Complete the following graph to show how the output voltage
VouT
varies
as
the
input voltage VIN is increased from -2 V to +2 V.
c)
gain
117) Design the DIBO-DA using the diode constant current bias to meet
the following specifications
a) supply voltage = 12V
b) Ie = 1.5 mA and Vbe = 0.7V.
c) voltage gain less than equal to 60.
118)
A differential amplifier has an output voltage given by Vo = 9
V2-10 V1.
The two inputs are V1 = 10 mV and V2 = 20 mv. Determine
common mode input voltage, common mode gain, the differential
gain, common mode output and CMRR.
.An opamp has slew rate of 0.5 V/Us .what is the maximum
frequency for which the amplifier will give an undistorted
sinusoidal output signal of (a) 30Vp-p (b) 50Vp-p.