Professional Documents
Culture Documents
Fall Protection Veriforce
Fall Protection Veriforce
Result BreakDown
Course VFS0164
15 Correct out of 1
Module 1
15 Correct out of 1
Objective 1
2 Correct out of 2
Objective 2
2 Correct out of 2
Objective 3
8 Correct out of 8
Objective 4
1 Correct out of 1
Objective 5
2 Correct out of 2
1
It is important to always be aware of your surroundings while at a job site.
2
Falls from lower than 7 feet do not usually cause injuries?
Fals
3
A pre-planning strategy significantly increases the number of fall hazards.
Fals
Category
Result BreakDown
4
Many workers fall each year from improper usage of _____.
a job hazard analysis
monitoring systems
toeboards
ladders
5
When working on a vertical surface, such as an electricity pole, a(n) _____ system is often used.
administrative
deceleration device
engineering
positioning device
6
Straps, slings, and beam trolleys are types of _____.
safety nets
toeboards
warning lines
anchorage connectors
7
Are workers allowed in the area between a warning line and unprotected edge?
8
The impact of a fall can be reduced by using _____ to limit the energy involved.
passive systems
safety nets
deceleration devices
Category
Result BreakDown
9
Passive protection systems are often preferred over active systems.
Fals
10
Which system stops falls in progress?
Passive
Active
11
Do you have to wear special equipment with passive systems?
12
The impact of a fall is distributed over the body with the use of a _____.
anchorage
connector
safety net
harness
13
How do canopies help keep workers safe?
They keep people away from areas where the potential of falling objects exists.
Vertical barriers at the edge of the walking level block objects from falling down.
Horizontal barriers across hole openings catch falling objects from above.
14
Category
Result BreakDown
Fall protection equipment should be stored in an area that is clean, dry, and moisture free.
Fals
15
When cleaning PFAS equipment, use only _____.
soft cloths
solvents
soapy water