Professional Documents
Culture Documents
Mapping of Basic Cisco Ios and System Management Commands To Junos Internet Software Commands
Mapping of Basic Cisco Ios and System Management Commands To Junos Internet Software Commands
Siew Ng
Network Support Engineer
Mapping of Basic Cisco IOS CLI and System Management Commands to JUNOS Internet Software Commands
Purpose
This note provides a mapping between basic Cisco CLI and system management commands
and the equivalent JUNOS Internet software commands. The purpose of this mapping is to
assist network professionals who are familiar with Cisco IOS commands in learning the
JUNOS Internet software. This note also serves as a command quick reference.
Category
IOS Command
clock set
set date
ping
ping
reload
send
request message
show clock
show environment
show history
show ip traffic
show logging
show log
show log file name
Show processes
show configuration
show tech-support
show users
show version
show version
show chassis hardware
terminal length
terminal width
trace
traceroute
clear counters
show interfaces
show interfaces
show interfaces detail
show interfaces extensive
show ip interface
show interfaces
show interfaces detail
show interfaces extensive
clear arp-cache
clear arp
show arp
show arp
show ip route
show route
show route-map
show policy
show policy policy-name
Interface Commands
Routing Protocol-Independent
Commands
Mapping of Basic Cisco IOS CLI and System Management Commands to JUNOS Internet Software Commands
Category
OSPF Commands
IS-IS Commands
BGP Commands
IOS Command
show tcp
clear isis *
clear ip bgp
show ip bgp
show route
advertising-protocol bgp
address
References
JUNOS Internet Software Configuration Guide Release 5.3
Cisco IOS Release 12.0 Configuration Guides and Command References
Copyright 2002, Juniper Networks, Inc. All rights reserved. Juniper Networks is registered in the U.S. Patent and Trademark Office and in other countries
as a trademark of Juniper Networks, Inc. Broadband Cable Processor, G10, Internet Processor, JUNOS, JUNOScript, M5, M10, M20, M40, M40e, M160,
M-series, ServiceGuard, T640, and T-series are trademarks of Juniper Networks, Inc. All other trademarks, service marks, registered trademarks, or registered
service marks are the property of their respective owners. All specifications are subject to change without notice.
Juniper Networks assumes no responsibility for any inaccuracies in this document. Juniper Networks reserves the right to change, modify, transfer, or otherwise
revise this publication without notice.