2005 Honda Pilot EX
2005 ELECTRICAL Under-dash Fuse/Relay Box - Pilot
2005 ELECTRICAL
Under-dash Fuse/Relay Box - Pilot
REMOVAL AND INSTALLATION
SRS components are located in this area, Review the SRS component locations (see
COMPONENT LOCATION INDEX ) and the precautions and procedures (see
PRECAUTIONS AND PROCEDURES ) before performing repairs or service.
REMOVAL,
1. Make sure you have the anti-theft codes for the radio and the navigation system, then
write down the frequencies for the radio's preset buttons.
2. Disconnect the negative battery cable, then disconnect the positive cable, and wait at
least 3 minutes
3. Driver's fuse box: Remove the left kick panel and dashboard lower cover (see
DRIVER'S DASHBOARD LOWER COVER REMOVAL/INSTALLATION ).
Passenger's fuse box: Remove the right kick panel and glove box (see GLOVE BOX
REMOVAL/INSTALLATION ).
4, Remove the mounting nut or bolt, and pull the driver's under-dash fuse/relay box (A) or
passenger's under-dash fuse/relay box (B) away from the body.2005 Honda Pilot EX
2005 ELECTRICAL Under-dash Fuse/Relay Box - Pilot
Fig. 1: Removing Mounting Nut Or Bolt2005 Honda Pilot EX
2005 ELECTRICAL Under-dash Fuse/Relay Box - Pilot
5.
Disconnect the driver's or passenger's under-dash fuse/relay box connectors, and remove
the driver's or passenger's under-dash fuse/relay box.
NOTE: The dashboard wire harness A (driver's under-dash
fuse/relay box connector B) 2P connector for SRS is a
spring-loaded lock type (see SPRING-LOADED LOCK
CONNECTOR ).
INSTALLATION
‘i
ww
Connect the connectors to the driver's or passenger's under-dash fuse/relay box, then
install the driver's or passenger's under-dash fuse/relay box in the reverse order of
removal.
. Install the removed parts in the reverse order of removal
.. Connect both the negative cable and positive cable to the battery, enter the anti-theft
codes for the radio and the navigation system, then enter the customer's radio station
presets, and set the clock.
Do the PCM idle learn procedure (see PCM IDLE LEARN PROCEDURE ).
. Reset the power window control unit (see RESETTING THE POWER WINDOW
CONTROL UNIT ).
.. Confirm that all systems work properly