Professional Documents
Culture Documents
(41103857) (Le Trung) (Analog Signal Processing) (Homework #3)
(41103857) (Le Trung) (Analog Signal Processing) (Homework #3)
ID: 41103857
b/
c/
Problem 2:
2.1:
a/ VTh = Vab open-circuit = 20n x
= 16 ()
= 5 (A)
b/
VTh
RTh = VTh
IN
2.2:
Using the same method we obtain VTh, RTh, IN for the following circuits:
VTh
RTh = VTh
IN = 5+0.3889 = 5.3889
VTh
RTh = VTh
IN
Problem3:
Sketch the circuit in PSPICE we obtain:
Problem 4:
4.1/
Vout is -15 V due to the VDC restraint of the Op-Amp in PSPICE (from -15V to 15V)
To have the Op-Amp function properly we should adjust this constraint from Property Editor
to be larger (-1000V to 1000 V for example)
Vout =-35 V
The Op=Amp
operates properly
We can see that after the constraint is removed, the Op-Amps functions properly,
|Vout|=3|Vin| and the two signals are different by in phase.
Problem 5:
5.1/
Using Matlab we obtain the transfer function of the desired filter:
H(w) =
Equate with the Sallen Key filtetr formula we obtain T1 = 4.5e-5, T2 = 2.25e-5
Choose R1 = 1k , R2 = 1k we obtain C1 = 4.5e-8, C2 = 2.25e-8
Realizing the filter in PSPICE we obtain the following circuit:
We can double-check by seeing that the cut-off frequency is at 5kHz (at this point, the
corresponding dB(Vout) is -0.3 dB
5.2/
Using the table provided in Analog Filter Design slides we can obtain these following values
(impedences and frequency are scaled already):
R1=R2=10k
L1=L2=0.86pH
C1=C3=3.28nF
C2=10.61nF
Realizing in PSPICE:
Same as 5.1, we now use AC sweep so that the transfer function diagram is obtained: