Professional Documents
Culture Documents
Chemtronics Overcoat Pen Circuitworks CW3300
Chemtronics Overcoat Pen Circuitworks CW3300
3rd Flr Unit C22 Banawe De Sta Rosa Phase 2 Balibago, Santa Rosa City, Laguna
Mob/Tel : 0933-5996622, 0932-8688548, ( 049) 5308463
lagunastar1@gmail.com , lagunastar2@gmail.com , lagunastar3@gmail.com
www.hanstartools.com , http://soldering102.blogspot.com
LOW COST, WILL GET THE JOB DONE VAT Reg. TIN 007-434-260-000
Applications:
Protects conductive pen traces
Repairs permanent solder
Prevents shorting and
CW3300C Clear 4.9 g (0.16
CW3300G Green 4.9 g (0.16
CW3300B Blue 4.9 g (0.16 oz)
CW3300BLACK Black 4.9 g (0.16 oz)
Origin = USA
============
Notes:
It is used to provide insulation of printed circuit boards, typically after rework and repair, where it can take the place of permanent solder
mask, solder resist or conformal coating. It was designed to insulate printed circuit board tracks, traces and components against high voltage
arcing. It also provides protection from moisture and fungus. The pen configuration is useful for rework when precision application is
necessary.
Applications
Directions
Use the Overcoat Pen for the protection of repaired tracks. Depress the pen on hard surface continuously until material is released and starts
to flow. Generously apply material over the repair surface. Make sure to overlap onto the original coating to ensure full coverage of
application. Allow 24 hours for complete cure at room temperature. For accelerated curing, place in oven for 20 minutes at 50C, and then
again for 30 minutes at 82C.