Quality ‘SAE 1018 Technical card
According to slandards ASTM A576-80b 2000 Hot rolled Lucefin Group
ASTM A SIIIA 311M: 2004 Cold drawn
Chemical composition
oh si% Mi P% 8% Product
max max deviations are
0.16020 a 0.80-0,90 0,040 0,050 allowed
$002 £0.08 + 0.008 + 0.008
NOTE: fine grain min. 5s spectied in the order, Al content shoul be of nat less than 0.020%
In case of 20.15 to 0.35% load addition, he stool is dented as 10L18
«the fllowng values are usualy specified atthe time of order placement: 0.10 max, 0.10-0.20, 0.16-0.35, 020-040, 0.90-0.60
Temperature °C
Hot forming Soft annealing +A Normalizing ‘Quenching Tempering
1180-300 650-700 920 880-900 ol polymer $60-620
furnace cooling air or water air
Pre-heating welding PWHT
not required slow cooing
Mechanical properties ASTM ASTIIA 311M: 200 Coltdrawn stvossoleved > 288 °C) c. A
size Testing at room temperature (ongiucina)
mm OR Rpo2 A reduc. HB
‘fom to Nima? min Nimm? min Semin Semin min
20485, a5 8 40 147
230 450 380 6 0 135
3050 415 345, 6 35 123,
5075 380 310 6 35 110
‘Cold-drawn mechanical propertes; Lucefin experience
flats Testing at room temperature (long tuna
mm oR Rpoz A Creduc. HB __M. elasticity Heat treatment
Nina? Nim? % % Ninn
76x32 584 556 134-607 ——176~—=—«253600~—=—*U uniroated
76x32 553 438 178 608 162 _——~251800_—_—~T~cali-drawn tempered at $50 °C
76x32 590 384 272-580 159 _—«186000-—~#T‘cald-drawn tempered at 620 °C
Hot rolled mechanical properies
size Testng at room temperature longitudinal Heat treatment
mm OR Rpo2 A Creduct HB Carburing at 925 °C, cooling at 250°C, heating at
Nima? Nim? % % 780°C, pause, then quenching in water and fal
2 64 386 a 8 3197 tempering at 180°C
£228 *oniveated
$180 *Aannealed