Professional Documents
Culture Documents
Manual Saeco Odea Go
Manual Saeco Odea Go
Before using the machine, please read the attached operating instructions.
Carefully read the safety rules
Mode d'emploi
Veuillez lire attentivement le mode d'emploi
(notamment les consignes de scurit) avant d'utiliser l'appareil.
IMPORTANT SAFEGUARDS
When using electrical appliances, basic safety precautions should always
be followed, including the following:
1. Read all instructions.
2. Do not touch hot surfaces. Use handles or knobs.
3. To protect against fire, electric shock and injury to persons do not
immerse cord, plugs, or appliance in water or other liquid.
4. Close supervision is necessary when the appliance is used by or near
children.
5. Unplug from outlet when not in use and before cleaning. Allow to
cool before putting on or taking off parts, and before cleaning the
appliance.
6. Do not operate any appliance with a damaged cord or plug or after the
appliance malfunctions, or has been damaged in any manner. Return
appliance to the nearest authorized service facility for examination,
repair or adjustment.
7. The use of accessory attachments not recommended by the appliance
manufacturer may result in fire, electric shock or injury to persons.
8. Do not use outdoors.
9. Do not let cord hang over edge of table or counter, or touch hot
surfaces.
10. Do not place on or near a hot gas or electric burner, or in a heated
oven.
11. Always attach plug to appliance first, then plug cord into wall outlet.
To disconnect, turn any control to off, then remove plug from wall
outlet.
12. Do not use appliance for other than intended use.
13. Save these instructions.
IMPORTANT
Lors de lutilisation dappareils lectriques, il est indispensable de respecter
toujours les prcautions de scurit principales, y compris les suivantes :
1. Lire toutes les instructions.
2. Ne pas toucher de surfaces chaudes. Utiliser les poignes ou les boutons.
3. Afin dviter tout incendie, choc lectrique et blessure, ne pas plonger
le cordon, la fiche ou lappareil dans leau ou dans nimporte quel
liquide.
4. Il est ncessaire de contrler attentivement lorsque lappareil est utilis
par des enfants ou leur proximit.
5. Dbrancher de la prise de courant lorsque lappareil nest pas en service
et avant son nettoyage. Laisser refroidir lappareil aussi bien avant de
retirer et de mettre en place ses accessoires quavant de le nettoyer.
6. Ne pas utiliser lappareil avec un cordon ou une fiche dtriors, aprs
un mauvais fonctionnement de lappareil ou son endommagement de
nimporte quelle manire. Renvoyer lappareil au centre dassistance
agr le plus proche pour tout contrle, rparation et rglage.
7. Lutilisation daccessoires non recommands par le constructeur de
lappareil pourrait engendrer des incendies, des chocs lectriques et des
blessures.
8. Ne pas utiliser lextrieur.
9. Ne pas laisser les cordons pendre des bords de la table ou du plan de
travail, ni toucher des surfaces chaudes.
10. Ne pas placer prs du feu ou sur une cuisinire, lectrique et gaz, ou
dans un four chaud.
11. Toujours brancher le cordon dalimentation la machine dabord et
ensuite la prise de courant sur le mur. Pour dbrancher, teindre toute
commande en appuyant sur OFF et ensuite enlever la fiche de la
prise de courant sur le mur.
12. Ne pas utiliser lappareil pour toute autre utilisation non prvue.
13. Garder ces instructions.
CAUTION
This appliance is for household use only. Any servicing, other than cleaning
and user maintenance, should be performed by an authorized service
centre. Do not immerse machine in water. To reduce the risk of fire or
electric shock, do not disassemble the machine. There are no parts inside
the machine serviceable by the user. Repair should be done by authorized
service personnel only.
1 Check voltage to be sure that the voltage indicated on the nameplate
corresponds with your voltage.
2 Never use warm or hot water to fill the water tank. Use cold water only.
3 Keep your hands and the cord away from hot parts of the appliance
during operation.
4 Never clean with scrubbing powders or harsh cleaners. Simply use a soft
cloth dampened with water.
5 For optimal taste of your coffee, use purified or bottled water. Periodic
descaling is still recommended every 2-3 months.
6 Do not use caramelized or flavored coffee beans.
PRCAUTIONS
INSTRUCTIONS SUR LE
CORDON ELECTRIQUE
A. Votre appareil est muni dun cordon lectrique court ou dun cordon
dalimentation dtachable, afin dviter de trbucher ou de semmler
avec un cble plus long.
B. Des cordons dtachables plus longs ou bien des rallonges sont
disponibles et ne peuvent tre utiliss que si lon prend toutes les
prcautions dusage.
C. En cas dutilisation dun long cordon dalimentation dtachable ou
dune rallonge,
1. La tension lectrique de fonctionnement marque sur le cordon dalimentation
dtachable ou sur la rallonge doit tre au moins gale celle de lappareil.
2. Si la fiche de lappareil a une connexion de terre, la rallonge devrait tre
une rallonge de terre 3 fils et
3. La rallonge ne devra pas encombrer le plan de travail ou le dessus de table,
afin dviter que les enfants la tirent ou trbuchent accidentellement.
INSTALLATION ..................................................................................................................................9
STARTING THE MACHINE .................................................................................................................................................... 9
RINSING OF THE INTERNAL CIRCUITS ............................................................................................................................ 10
INSTALLING THE INTENZA WATER FILTER (OPTIONAL) ..................................................................................................11
TROUBLESHOOTING .....................................................................................................................30
SAFETY RULES ..............................................................................................................................32
TECHNICAL DATA...........................................................................................................................36
GNRALITS ..................................................................................................................................7
APPAREIL..........................................................................................................................................8
ACCESSOIRES ...................................................................................................................................................................... 8
MONTAGE .........................................................................................................................................9
MISE EN MARCHE DE LA MACHINE .................................................................................................................................... 9
RINAGE DES CIRCUITS INTERNES ................................................................................................................................ 10
FILTRE EAU INTENZA (EN OPTION) ................................................................................................................................11
CAPPUCCINO .................................................................................................................................20
DTARTRAGE .................................................................................................................................23
NETTOYAGE ET ENTRETIEN ........................................................................................................26
ENTRETIEN PENDANT LE FONCTIONNEMENT ............................................................................................................... 26
NETTOYAGE DE LA MACHINE............................................................................................................................................ 27
NETTOYER LE GROUPE DE DISTRIBUTION .................................................................................................................... 28
7
GENERAL INFORMATION
This coffee machine is suitable for preparing espresso coffee using coffee beans and it is equipped with
a device to dispense steam and hot water. The machine is designed for domestic use and is not suitable
for heavy or professional use. Warning: no liability is assumed for any damage caused by:
incorrect use not in accordance with the intended uses;
repairs not carried out by authorized customer service centres;
tampering with the power cable;
tampering with any part of the machine;
the use of non-original spare parts and accessories;
failure to descale the machine or use at temperatures below 0C (32F).
APPLIANCE - APPAREIL
Cup warming surface
Plaque pour poser les tasses
Control panel
Tableau de commande
Service door
Porte de service
Dispensing head
Distributeur
Dregdrawer
Tiroir marc
Brew group
Groupe de distribution
Drip tray
Bac de rcupration liquides
Water tank
Rservoir deau
ACCESSORIES - ACCESSOIRES
Power cable
Cble dalimentation
Grinder adjustment key
Cl pour rgler la mouture
Intenza water filter (optional)
Filtre eau Intenza (en option)
INSTALLATION - MONTAGE
10
INSTALLATION - MONTAGE
8
10
11
12
Retirer le rcipient.
11
NOTE: if the Intenza water filter is not used, insert the small white filter that was previously removed (step 1) into the water tank.
REMARQUE : Si le filtre eau Intenza nest pas prsent, insrer dans le rservoir le petit filtre blanc prcdemment enlev.
12
Description - Description
Coffee button:
the button has been pushed once: 1 coffee has been selected.
the button has been pushed twice: 2 coffees have been selected.
Bouton de distribution du caf :
touche appuye une fois : 1 caf slectionn.
touche appuye deux fois : 2 cafs slectionns.
Hot water/steam button:
on: steam function is selected
off: hot water function is selected
Bouton de distribution deau chaude:
allum : la machine distribue de la vapeur
teint : la machine distribue de leau chaude.
Coffee dose adjusting knob (see page 14).
13
LED Light - Touche / DEL
Description - Description
Alarm light:
permanently on : signals the machine is out of coffee, the water tank is
empty, the drip tray is full or the dregdrawer is full (in this case, also empty
the coffee grounds drawer in order to prevent failures).
on and flashing slowly: signals that the brew group is not inserted, the
dregdrawer is not inserted the coffee bean hopper lid is not on, the service
door is open or the steam/hot water knob is not correctly turned to the
desired position.
on and quickly flashing: signals the need to prime the water circuit.
DEL (diode lumineuse) alarme :
allume de manire fixe (un ou plusieurs vnements) : signale :
un manque de caf ; rservoir de leau vide, besoin de vider le bac de
rcupration des liquides (Dans ce cas, veiller aussi vider et nettoyer le
bac marcs de caf, pour viter un blocage).
allume clignotement lent (un ou plusieurs vnements) : signale
: absence du groupe de distribution, tiroir marc non insr, couvercle
du rservoir caf non insr, porte de service ouverte, bouton de
distribution de leau chaude/vapeur tourn incorrectement dans la position
souhaite.
allume clignotement rapide : signale la ncessit de ramorcer le
circuit de leau.
If the
and
lights flash alternately: turn off the machine. Turn it on again after 30 seconds, wait until the
machine stops and then turn it off again. Remove and thoroughly clean the brew group (see page 28). If this
signal appears again when the machine is turned back on, contact the customer service centre.
Led
et
clignotant tour de rle : teindre la machine. Au bout de 30 secondes, remettre en marche la
machine et attendre quelle sarrte ; teindre nouveau la machine. Retirer et nettoyer soigneusement le groupe de
distribution (voir page 28). Si la signalisation se reproduit la remise en marche, contacter le centre dassistance.
14
ADJUSTMENTS - RGLAGES
COFFEE VOLUME ADJUSTMENT PER CUP
QUANTITE DU CAF EN TASSE
The coffee volume knob adjusts the
amount of coffee brewed per cup.
This adjustment has an immediate
effect on the selected type of
brewing.
Pour rgler la quantit de caf
distribue dans une tasse.
Ce rglage a un effet immdiat sur
la distribution slectionne.
Medium coffee
Caf moyen
Espresso coffee
Caf expresso
Long coffee
Caf allong
15
STAND-BY - STAND-BY
The machine is designed for energy saving. After 60 minutes
of inactivity, the machine goes into stand-by mode, the boiler is
no longer heated and all the lights turn off with the exception of
the temperature light which will blink slowly.
Power consumption is reduced to a minimum.
To turn the machine on again simply press the brew button.
The machine will go through the rinse cycle if the circuit is
cold.
La machine a t conue pour l'conomie d'nergie. La
machine se met en attente (stand-by) 60 minutes aprs la
dernire utilisation, la chaudire nest plus alimente, toutes
les DEL steignent lexception des DEL de temprature qui
clignoteront lentement.
Les consommations sont rduites au minimum.
Pour redmarrer la machine, il suffira dappuyer sur la touche
caf. La machine effectuera le rinage au cas o le circuit se
serait refroidi.
16
ADJUSTMENTS - RGLAGES
SAECO ADAPTING SYSTEM
SAECO ADAPTING SYSTEM
Coffee is a natural product and its characteristics may change according to its origin, blend and roast. The
Saeco coffee machine is equipped with a self-adjusting system that allows the use of all types of coffee
beans available on the market (not including flavored or carmelized).
The machine automatically adjusts itself in order to optimize the extraction of the coffee, ensuring perfect
compression of the beans to obtain a creamy espresso coffee that is able to release all the aromas,
regardless of the type of coffee used.
The optimization process is a learning process that requires the brewing of a certain number of coffees
to allow the machine to adjust the compactness of the ground coffee.
Attention should be given to special blends, which require grinder adjustments in order to optimize the
extraction of the coffee (see page 17).
Le caf est un produit naturel et ses caractristiques peuvent changer selon son origine, son mlange et
sa torrfaction. La machine caf Saeco est munie dun systme dautorglage permettant dutiliser tout
type de caf en grains disponible dans le commerce (non caramlis).
La machine se rgle automatiquement afin doptimiser l'extraction du caf, en assurant le compactage
parfait de la pastille pour prparer un caf expresso crmeux, mme de librer tous les armes,
indpendamment du type de caf utilis.
Le processus doptimisation se compose d'une phase de calibrage demandant la distribution dun
certain nombre de cafs afin de permettre la machine de rgler le compactage de la poudre.
Attention, il peut y avoir des mlanges particuliers qui demandent un rglage des moulins dans le but
doptimiser lextraction du caf - (voir page 17).
17
COFFEE GRINDER ADJUSTMENT - RGLAGE DU MOULIN
The machine enables a slight adjustment of the coffee grinder. Coffee may be ground according to your
own tastes.
The adjustment must be performed using the small pin located inside the coffee bean hopper. This must
be pressed and turned using the supplied grinder adjustment key only. Press and turn the pin one notch
at a time and brew 2-3 cups of coffee; the variation in grind may only be noticed in this way.
The references located inside the container indicate the grind
setting.
La machine permet de rgler le degr de mouture du caf.
Ceci dans le but dadapter la distribution du caf au got
personnel de chacun.
Le rglage doit tre effectu laide du pivot situ lintrieur
du rservoir caf ; appuyer sur le pivot et le tourner
uniquement avec la cl fournie. Presser et tourner le pivot
dun seul cran la fois et distribuer 2 ou 3 cafs : cest le seul
moyen pour remarquer la variation du degr de mouture.
Les rfrences lintrieur du rservoir indiquent le degr de
mouture rgl.
COARSE GRIND
MOUTURE GROSSIRE
MEDIUM GRIND
MOUTURE MOYENNE
FINE GRIND
MOUTURE FINE
18
19
HOT WATER DISPENSING - DISTRIBUTION DEAU CHAUDE
Dispensing may be preceded by short sprays of hot water, and scalding is possible. The
hot water/steam wand may reach high temperatures: do not touch it with bare hands. Use
the appropriate handle only.
Au dbut de la distribution, faire attention au risque de brlures car il peut y avoir
des claboussures deau chaude. La buse deau chaude/vapeur peut atteindre des
tempratures leves : viter de la toucher directement avec les mains, utiliser exclusivement la
poigne prvue cet effet.
20
CAPPUCCINO
CAPPUCCINO
Dispensing may be preceded by short sprays of hot water, and scalding is possible. The
hot water/steam spout may reach high temperatures: do not touch it with bare hands. Use
the appropriate handle only.
Au dbut de la distribution, faire attention au risque de brlures car il peut y avoir
des claboussures deau chaude. La buse deau chaude/vapeur peut atteindre des
tempratures leves : viter de la toucher directement avec les mains, utiliser exclusivement la
poigne prvue cet effet.
21
7
10
11
12
13
14
15
22
CAPPUCCINO
16
17
After frothing the milk, brew
coffee into the cup for a
creamy cappuccino.
DESCALING - DTARTRAGE
23
DESCALING - DTARTRAGE
When performing a descaling cycle, it is necessary to be present during the entire process
(about 40 minutes).
Caution! Do not use vinegar as a descaler.
Descaling should be performed every 3 months, or when indicated by the machine. Use a non-toxic, nonharmful descaling solution.
Saeco descaling solution is recommended.
The used solution should be disposed according to the manufacturer instructions and/or regulations in the
country of use.
Note: before starting a descaling cycle make sure that:
1 a container of adequate size is available;
2 the water filter (if inserted) has been removed.
Lorsquon procde au dtartrage, il faut tre prsent pendant toute la
dure du processus (environ 40 minutes).
Attention ! Ne jamais utiliser de vinaigre pour dtartrer la machine.
Le dtartrage doit tre effectu lorsque la machine le signale. Dans tous les cas, il
doit tre ralis au moins tous les 3 mois en suivant les indications dcrites partir du point (2). Utiliser
un dtartrant non toxique ou non nocif. Nous recommandons lemploi de la solution dtartrante
SAECO disponible auprs de votre revendeur ou de votre SAV.
La solution utilise doit tre limine conformment ce qui est prvu par le fabricant et/ou par les
normes en vigueur dans le pays o la machine est utilise.
Remarque : avant de commencer le dtartrage, sassurer que :
1 le rcipient a la bonne dimension ;
2 le filtre eau, si prsent, a t enlev.
1
24
DESCALING
25
10
11
12
13
14
26
The indicator light to empty the dregdrawer illuminates approximately every 15 coffee cycles. If the dregdrawer
is emptied with the machine turned off, or when the indicator light is not illuminated (see page 12), the count of
the coffee cycles is not reset. For this reason, the indicator light to empty the dregdrawer may illuminate even
when it is not full.
En vidant les marcs lorsque la machine est teinte ou quand la DEL alarme vider marcs nest pas allume
(voir page 12,), le comptage des marcs dposs dans le tiroir nest pas remis zro. Pour cette raison, la DEL
alarme vider marcs peut sallumer mme aprs avoir prpar peu de cafs.
27
HOW TO CLEAN THE MACHINE - NETTOYAGE DE LA MACHINE
The machine must be cleaned at least once a week.
Do not immerse the machine in water or place any of its parts in a dishwasher.
Do not use alcohol, solvents, benzene and/or abrasive objects to clean the machine.
The water left in the tank for several days must be disposed of.
Do not dry the machine and/or its components using a microwave and/or conventional oven.
Le nettoyage de la machine doit tre effectu au moins une fois par semaine.
Ne pas immerger la machine dans leau. Ne pas laver les composants au lave-vaisselle.
Ne pas utiliser dalcool thylique, de solvants, dessences et/ou dobjets abrasifs pour le
nettoyage de la machine. Leau qui est reste dans le rservoir pendant plusieurs jours doit tre
retire du rservoir en la vidant. Ne pas scher la machine et/ou ses composants dans un four
micro-ondes et/ou un four traditionnel.
teindre la machine et
dbrancher la prise.
28
29
4
30
TROUBLESHOOTING
PROBLEMS
CAUSES
SOLUTIONS
Machine in stand-by.
The machine grinds the coffee beans but Water tank is empty.
no coffee comes out.
Brew group is dirty.
(see note)
Circuit is not primed.
Note: If dealing with an initial start-up or if the coffee blend has been changed, a certain number of coffees must be
brewed in order to allow the machine to optimize the parameters.
Please contact the service center for any problems not covered in the above table or when the suggested solutions
do not solve the problem.
CAUSES
La machine nest pas branche sur le
rseau lectrique.
La fiche nest pas branche sur la prise
situe au dos de la machine.
Machine en attente (Stand-by).
31
REMDES
Brancher la machine sur le rseau lectrique.
Brancher la fiche sur la prise de la machine.
Appuyer sur la touche caf pour faire
dmarrer la machine.
Rchauffer les tasses en y distribuant de
leau chaude.
Nettoyer le trou de la buse de vapeur laide
dune aiguille.
Changer le mlange de caf.
Dtartrer la machine.
Remarque : sil sagit dune premire mise en service ou si le mlange de caf a t chang, la distribution dun
certain nombre de cafs est ncessaire de faon ce que la machine optimise les paramtres.
Pour toute panne non dtaille dans le tableau ci-dessus ou en cas de solutions insuffisantes, sadresser un centre
dassistance agr.
32
SAFETY RULES
IN CASE OF EMERGENCY
Immediately unplug the cable from the outlet.
- Indoors.
- To prepare coffee, dispense hot water, froth milk or heat beverages using steam.
- For domestic use only.
POWER CONNECTION
Only connect the coffee machine to a suitable power socket. The voltage must correspond to the indication on the
machines label.
INSTALLATION
-
DANGER
- This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental
capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction
concerning use of the appliance by a person responsible for their safety.
- Children should be supervised to ensure that they do not play with the appliance.
- The appliance is dangerous to children. If left unattended, please disable it.
- Do not leave the coffee machine packaging within the reach of children.
- Never direct the jet of hot water and/or steam towards yourself or others. Danger of scalding.
- Do not insert objects through the appliances openings (Danger! Electrical current!).
- Do not touch the plug with wet hands and feet. Do not remove the plug by pulling the cable.
- Warning, danger of burns caused by hot water, steam and hot water/steam spout.
CONSIGNES DE SCURIT
33
EN CAS DURGENCE
Dbrancher immdiatement la fiche de la prise murale.
MONTAGE
- Choisir un plan dappui plat et bien nivel ; Ne pas poser la machine sur des surfaces incandescentes !
- Placer la machine au moins 10 cm du mur ou dune plaque de cuisson.
- Ne pas exposer la machine une temprature infrieure 0 C, au risque de provoquer des dommages dus
au gel.
- Lutilisateur doit pouvoir accder la prise de courant tout moment.
- Le cble dalimentation ne doit pas tre endommag, li avec des serre-cbles, plac sur des surfaces
incandescentes, etc.
- Ne pas laisser pendre le cble dalimentation. (Att. : Vous risquez de trbucher ou de faire tomber lappareil).
- Ne pas transporter ni tirer la machine par le cble.
DANGERS
- Lappareil nest pas destin tre employ par des personnes (y compris les enfants) avec de faibles
capacits physiques, mentales ou sensorielles ou avec exprience et/ou des comptences insuffisantes,
moins quelles ne soient sous la supervision dune personne responsable de leur scurit ou quelles ne soient
instruites par cette personne en ce qui concerne lemploi de lappareil.
- Garder les enfants sous supervision, afin dviter quils ne jouent avec lappareil.
- Lappareil est dangereux pour les enfants. Sil est sans surveillance, lteindre.
- Ne pas laisser les matriaux demballage de la machine la porte des enfants.
- Ne pas diriger le jet deau chaude et/ou de vapeur vers soi et/ou vers dautres personnes : risque de brlures.
- Ne pas introduire dobjets dans les orifices de lappareil (Danger ! Courant lectrique !).
- Ne pas toucher la prise avec les mains ou les pieds mouills et ne pas la dbrancher de la prise murale en
34
SAFETY RULES
FAILURES
- Do not use the appliance in case of sure or suspected faults such as after falls.
- Any repairs must be performed by an authorized customer service center.
- Do not use the appliance with a defective power cable. If damaged, the power cable must be replaced by the
manufacturer or authorized service centre. (Caution! Electrical current).
- Turn off the appliance before opening the service door.
CLEANING / DESCALING
- Before cleaning, unplug the machine and let the appliance cool.
- Keep the appliance from coming into contact with splashes of water or immersing in water.
- Do not dry the machines parts in conventional or microwave ovens.
SPARE PARTS
For safety reasons, use only original spare parts and original accessories.
DISPOSAL
on the product or on its packaging indicates that this product may not be treated as
The symbol
household waste. Instead it shall be handed over to the applicable collection point for the recycling of electrical
and electronic equipment.
By ensuring this product is disposed of correctly, you will help prevent potential negative consequences for
the environment and human health, which could otherwise be caused by inappropriate waste handling of this
product. For more detailed information about recycling of this product, please contact your local city office, your
household waste disposal service or the retailer where you purchased the product.
ADDITIONAL INFORMATION FOR THE CORRECT USE OF THE INTENZA WATER FILTER
To correctly use the Intenza water filter, please consider the following instructions:
1. Store the water filter in a cool area in which the room temperature is between +1C to +50C (34F to 122F).
Do not store it in direct sunlight.
2. Carefully read the operating instructions and the safety warnings provided with each filter.
3. Keep the filter instructions together with the manual.
4. These instructions integrate the ones in the manual, as they take into consideration the specific application of
the filter in the machine.
CONSIGNES DE SCURIT
35
PANNES
- Ne pas utiliser lappareil en cas de panne identifie ou suspecte, par ex. aprs une chute.
- Les ventuelles rparations doivent tre effectues par un service dassistance agr.
- Ne pas utiliser un appareil prsentant un cble dalimentation dfectueux. Si le cble dalimentation est abm,
celui-ci doit tre remplac par le constructeur ou par son service clients. (Danger ! Courant lectrique !).
- teindre dappareil avant douvrir la porte de service.
NETTOYAGE / DTARTRAGE
PICES DE RECHANGE
Pour des raisons de scurit, nutiliser que des pices de rechange et daccessoires dorigine.
DMOLITION
L appareil est en conu et fabriqu pour faciliter sa valorisation, son recyclage ou sa rutilisation conformment
la directive europenne 2002/96/CEE relative aux appareils lectriques et lectroniques usags (waste
electrical and electronic equipment - WEEE).
Le logo
ci-contre appos sur lappareil indique que ce produit ne peut pas tre limin avec les
dchets mnagers non tris.
Lorsque vous aurez dcid de vous en sparer dfinitivement, il convient de faire procder la collecte slective
de cet appareil en vous conformant au mode de reprise mis en place dans votre commune (collecte ponctuelle
des encombrants, dchterie), ou en faisant appel au service de reprise propos par votre distributeur, ou bien,
en le confiant des organisations caritatives et des associations but non lucratif.
En vous assurant que ce produit est limin correctement, vous favorisez la prvention des consquences
ngatives pour lenvironnement et la sant humaine.
36
Nominal voltage
Power rating
Power supply
Shell material
Size (w x h x d)
Weight
Cable length
Control panel
Water tank
Pump pressure (bars)
Boiler
Coffee bean hopper capacity
Quantity of ground coffee
Grounds drawer capacity
Safety devices
Subject to engineering and manufacturing changes due to technological developments. The machine
conforms to the European Directive 89/336/EEC (Italian Legislative Decree 476 dated 04/12/92) concerning
electromagnetic compatibility.
DONNES TECHNIQUES
Tension nominale
Puissance nominale
Alimentation
Matriau du corps
Dimensions (l x h x p) (mm)
Poids (kg)
Longueur du cble (mm)
Tableau de commande
Rservoir deau (l)
Pression de la pompe (bar)
Chaudire
Capacit du rservoir caf (g)
Quantit de caf moulu
Capacit du tiroir marc
Dispositifs de scurit
37
38
EC DECLARATION OF CONFORMITY
EC 2006/95, EC 2004/118,
EC 1992/31, EC 1993/68
SUP 031O
to which this declaration relates is in conformity with the following standards or other normative documents :
R & D Manager
Gaggio Montano - li, 27/06/2007
39
DECLARATION DE CONFORMIT CE
EC 2006/95, EC 2004/118,
EC 1992/31, EC 1993/68
SUP 031O
auquel se rfre cette dclaration est conforme aux normes suivantes :
Scurit dappareils lectromnagers et lectriques - Prescriptions gnrales
EN 60335-1 (2002) + A1(2004) + A2(2006) + A11(2004) + A12 (2006)
Scurit dappareils lectromnagers et lectriques - Partie 2-15
Prescriptions particulires pour les appareils de chauffage des liquides
EN 60 335-2-15 (2002) + A1(2005)
Scurit des appareils pour usage domestique et analogue. Champs lectromagntiques
Mthodes pour lvaluation et les mesures EN 50366 (2003) + A1 (2006).
Scurit dappareils lectromnagers et lectriques - Partie 2-14
Prescriptions particulires pour poulvrisateurs et moulins caf EN 60335-2-14 (2006).
Limites et mthodes de mesure des perturbations radio produites par les appareils lectromnagers ou
analogues com lectriques ou des dispositifs thermiques, par les outils lectriques et par les
appareils lectriques analogues - EN 55014-1 (2000) + A1 (2001) + A2 (2002)
Compatibilit lectromagntique (CEM)
Partie 3 Limites - Section 2 : Limites pour les missions de courant harmonique (courant
appel par les appareils 16A par phase) - EN 61000-3-2 (2000)
Compatibilit lectromagntique (CEM)
Partie 3 Limites - Section 3 : Limitation des variations et des fluctuations de tension et du papillotement dans
les rseaux dalimentation basse tension pour appareils ayant un courant nominal 16A.
EN 61000-3-3 (1995) + A1(2001)
Prescriptions dimmunit pour les appareils lectromnagers, outils lectriques et appareils analogues.
Norme de famille de produits EN 55014-2 (1997) + A1 (2001)
suivant les dispositions des directives CE 73/23, CE 89/336, CE 92/31, CE 93/68.
R & D Manager
Mr. Andrea Castellani